Lucas Red ?N? Tacky NLGI # 2 grease Not available. GHS product identifier Other means of identification Emergency telephone number (with hours of operation) Section 1. Identification : : : Relevant identified uses of the substance or mixture and uses advised against Conforms to HazCom 2012/United States SAFETY DATA SHEET Lucas Red ?N? Tacky NLGI # 2 grease Engine oil. (951) 493-1149 (951) 847-5949 This email address is being protected from spambots. You need JavaScript enabled to view it. 7:00A.M. to 5:00P.M. Monday thru Friday Product number : 10005, 10027, 10028, 10029, 10574 : Lucas Oil Products, Inc 302 North Sheridan Street Corona, California 92880-2067 Toll Free: (800) 342-2512 Tel: (951) 270-0154 Fax: (951) 270-1902 Website: www.LucasOil.com Supplier's details Section 2. Hazards identification SERIOUS EYE DAMAGE/ EYE IRRITATION - Category 1 AQUATIC HAZARD (LONG-TERM) - Category 3 Classification of the substance or mixture : Signal word : Danger Hazard statements : Causes serious eye damage. Harmful to aquatic life with long lasting effects. Hazard pictograms : Precautionary statements Prevention : Wear eye or face protection. Avoid release to the environment. Wash hands thoroughly after handling. GHS label elements General : Read label before use. Keep out of reach of children. If medical advice is needed, have product container or label at hand. OSHA/HCS status : This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200). 1/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 2. Hazards identification Response : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a POISON CENTER or physician. Storage : Not applicable. Disposal : Dispose of contents and container in accordance with all local, regional, national and international regulations. Hazards not otherwise classified : None known. Section 3. Composition/information on ingredients Zinc Alkyldithiophosphate 1 - 5 68649-42-3 Ingredient name CAS number% There are no additional ingredients present which, within the current knowledge of the supplier and in the concentrations applicable, are classified as hazardous to health or the environment and hence require reporting in this section. Other means of identification : Not available. CAS number : Not applicable. Substance/mixture Product code : Not available. CAS number/other identifiers : Occupational exposure limits, if available, are listed in Section 8. Mixture Any concentration shown as a range is to protect confidentiality or is due to batch variation. Get medical attention immediately. Call a poison center or physician. Immediately flush eyes with plenty of water, occasionally lifting the upper and lower eyelids. Check for and remove any contact lenses. Continue to rinse for at least 20 minutes. Chemical burns must be treated promptly by a physician. Get medical attention immediately. Call a poison center or physician. Wash contaminated skin with soap and water. Wash contaminated clothing thoroughly with water before removing it, or wear gloves. Continue to rinse for at least 20 minutes. Chemical burns must be treated promptly by a physician. Wash clothing before reuse. Clean shoes thoroughly before reuse. Get medical attention immediately. Call a poison center or physician. Remove victim to fresh air and keep at rest in a position comfortable for breathing. If it is suspected that fumes are still present, the rescuer should wear an appropriate mask or self-contained breathing apparatus. If not breathing, if breathing is irregular or if respiratory arrest occurs, provide artificial respiration or oxygen by trained personnel. It may be dangerous to the person providing aid to give mouth-to-mouth resuscitation. If unconscious, place in recovery position and get medical attention immediately. Maintain an open airway. Loosen tight clothing such as a collar, tie, belt or waistband. Section 4. First aid measures Eye contact Skin contact Inhalation : : : Description of necessary first aid measures 2/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 4. First aid measures Get medical attention immediately. Call a poison center or physician. Wash out mouth with water. Remove dentures if any. Remove victim to fresh air and keep at rest in a position comfortable for breathing. If material has been swallowed and the exposed person is conscious, give small quantities of water to drink. Stop if the exposed person feels sick as vomiting may be dangerous. Do not induce vomiting unless directed to do so by medical personnel. If vomiting occurs, the head should be kept low so that vomit does not enter the lungs. Chemical burns must be treated promptly by a physician. Never give anything by mouth to an unconscious person. If unconscious, place in recovery position and get medical attention immediately. Maintain an open airway. Loosen tight clothing such as a collar, tie, belt or waistband. Ingestion : Protection of first-aiders : No action shall be taken involving any personal risk or without suitable training. If it is suspected that fumes are still present, the rescuer should wear an appropriate mask or self-contained breathing apparatus. It may be dangerous to the person providing aid to give mouth-to-mouth resuscitation. Wash contaminated clothing thoroughly with water before removing it, or wear gloves. Notes to physician : Treat symptomatically. Contact poison treatment specialist immediately if large quantities have been ingested or inhaled. Specific treatments : No specific treatment. Most important symptoms/effects, acute and delayed Inhalation : May give off gas, vapor or dust that is very irritating or corrosive to the respiratory system. May cause burns to mouth, throat and stomach.:Ingestion Skin contact : No known significant effects or critical hazards. Causes serious eye damage.:Eye contact Over-exposure signs/symptoms Skin contact Ingestion Inhalation No known significant effects or critical hazards. No known significant effects or critical hazards. No known significant effects or critical hazards. : : : Eye contact : No known significant effects or critical hazards. Potential acute health effects See toxicological information (Section 11) Indication of immediate medical attention and special treatment needed, if necessary Section 5. Fire-fighting measures Hazardous thermal decomposition products Specific hazards arising from the chemical No specific data. No specific fire or explosion hazard. Use an extinguishing agent suitable for the surrounding fire. Extinguishing media : : None known. Suitable extinguishing media : Unsuitable extinguishing media : 3/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 5. Fire-fighting measures No special precaution is required. Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode. Special protective equipment for fire-fighters : Special protective actions for fire-fighters : Section 6. Accidental release measures Environmental precautions Personal precautions, protective equipment and emergency procedures Move containers from spill area. Approach release from upwind. Prevent entry into sewers, water courses, basements or confined areas. Avoid dust generation. Do not dry sweep. Vacuum dust with equipment fitted with a HEPA filter and place in a closed, labeled waste container. Dispose of via a licensed waste disposal contractor. Note: see Section 1 for emergency contact information and Section 13 for waste disposal. : : No action shall be taken involving any personal risk or without suitable training. Keep unnecessary and unprotected personnel from entering. Do not touch or walk through spilled material. Provide adequate ventilation. Wear appropriate respirator when ventilation is inadequate. Put on appropriate personal protective equipment. Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers. Inform the relevant authorities if the product has caused environmental pollution (sewers, waterways, soil or air). Water polluting material. May be harmful to the environment if released in large quantities. Large spill : Move containers from spill area. Avoid dust generation. Using a vacuum with HEPA filter will reduce dust dispersal. Place spilled material in a designated, labeled waste container. Dispose of via a licensed waste disposal contractor. Small spill : Methods and materials for containment and cleaning up For non-emergency personnel For emergency responders : If specialized clothing is required to deal with the spillage, take note of any information in Section 8 on suitable and unsuitable materials. See also the information in "For non- emergency personnel". Section 7. Handling and storage Advice on general occupational hygiene Conditions for safe storage, including any incompatibilities Eating, drinking and smoking should be prohibited in areas where this material is handled, stored and processed. Workers should wash hands and face before eating, drinking and smoking. See also Section 8 for additional information on hygiene measures. Store in accordance with local regulations. Store in original container protected from direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials (see Section 10) and food and drink. Store locked up. Keep container tightly closed and sealed until ready for use. Containers that have been opened must be carefully resealed and kept upright to prevent leakage. Do not store in unlabeled containers. Use appropriate containment to avoid environmental contamination. : : Protective measures Put on appropriate personal protective equipment (see Section 8). Do not get in eyes or on skin or clothing. Do not ingest. Avoid release to the environment. If during normal use the material presents a respiratory hazard, use only with adequate ventilation or wear appropriate respirator. Keep in the original container or an approved alternative made from a compatible material, kept tightly closed when not in use. Empty containers retain product residue and can be hazardous. Do not reuse container. : Precautions for safe handling 4/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 8. Exposure controls/personal protection Hand protection Use a properly fitted, particulate filter respirator complying with an approved standard if a risk assessment indicates this is necessary. Respirator selection must be based on known or anticipated exposure levels, the hazards of the product and the safe working limits of the selected respirator. Chemical-resistant, impervious gloves complying with an approved standard should be worn at all times when handling chemical products if a risk assessment indicates this is necessary. Considering the parameters specified by the glove manufacturer, check during use that the gloves are still retaining their protective properties. It should be noted that the time to breakthrough for any glove material may be different for different glove manufacturers. In the case of mixtures, consisting of several substances, the protection time of the gloves cannot be accurately estimated. Safety eyewear complying with an approved standard should be used when a risk assessment indicates this is necessary to avoid exposure to liquid splashes, mists, gases or dusts. If contact is possible, the following protection should be worn, unless the assessment indicates a higher degree of protection: chemical splash goggles and/ or face shield. If inhalation hazards exist, a full-face respirator may be required instead. Eye/face protection Respiratory protection : : : Body protection Personal protective equipment for the body should be selected based on the task being performed and the risks involved and should be approved by a specialist before handling this product. : Environmental exposure controls : Emissions from ventilation or work process equipment should be checked to ensure they comply with the requirements of environmental protection legislation. Appropriate engineering controls : If user operations generate dust, fumes, gas, vapor or mist, use process enclosures, local exhaust ventilation or other engineering controls to keep worker exposure to airborne contaminants below any recommended or statutory limits. Wash hands, forearms and face thoroughly after handling chemical products, before eating, smoking and using the lavatory and at the end of the working period. Appropriate techniques should be used to remove potentially contaminated clothing. Wash contaminated clothing before reusing. Ensure that eyewash stations and safety showers are close to the workstation location. Hygiene measures : Control parameters Individual protection measures Occupational exposure limits Skin protection Other skin protection : Appropriate footwear and any additional skin protection measures should be selected based on the task being performed and the risks involved and should be approved by a specialist before handling this product. None. Section 9. Physical and chemical properties Physical state Melting point Solid. [Grease.] Not available. Mild. Petroleum oil.Odor pH Red.Color Not applicable. Not available.Odor threshold : : : : : : Appearance Boiling point : Not available. 5/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 9. Physical and chemical properties Vapor pressure Relative density Vapor density Solubility 0.9 Not available. Not available. Negligible at 25oC Evaporation rate Not available. Auto-ignition temperature Flash point Not available. Not available. Not available. Viscosity Kinematic (100?C (212?F)): 0.19 cm2/s (19 cSt) Partition coefficient: n- octanol/water : : : : : : : : : Flammability (solid, gas) : Not available. Lower and upper explosive (flammable) limits : Not available. Burning rate Not available.: Burning time : Not available. SADT Not available.: Decomposition temperature : Not available. Solubility in water : 0 g/l Section 10. Stability and reactivity Hazardous decomposition products Conditions to avoid Excessive heat. Under normal conditions of storage and use, hazardous decomposition products should not be produced. The product is stable.Chemical stability Reactive or incompatible with the following materials: strong oxidizers. : : : Incompatible materials : Possibility of hazardous reactions : Under normal conditions of storage and use, hazardous reactions will not occur. Reactivity : No specific test data related to reactivity available for this product or its ingredients. Section 11. Toxicological information Acute toxicity Irritation/Corrosion Zinc Alkyldithiophosphate Eyes - Irritant Rabbit - - - Product/ingredient name Result Score Exposure Observation Sensitization Species Information on toxicological effects There is no data available. Skin : Respiratory : There is no data available. There is no data available. 6/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 11. Toxicological information Carcinogenicity Mutagenicity Teratogenicity Reproductive toxicity Information on the likely routes of exposure Inhalation : May give off gas, vapor or dust that is very irritating or corrosive to the respiratory system. May cause burns to mouth, throat and stomach.:Ingestion Skin contact : No known significant effects or critical hazards. Causes serious eye damage.:Eye contact No known significant effects or critical hazards.General : No known significant effects or critical hazards.Carcinogenicity : No known significant effects or critical hazards.Mutagenicity : No known significant effects or critical hazards.Teratogenicity : Developmental effects : No known significant effects or critical hazards. Symptoms related to the physical, chemical and toxicological characteristics Skin contact Ingestion Inhalation No known significant effects or critical hazards. No known significant effects or critical hazards. No known significant effects or critical hazards. : : : Eye contact : No known significant effects or critical hazards. Potential chronic health effects Delayed and immediate effects and also chronic effects from short and long term exposure Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard : Potential acute health effects Potential immediate effects : No known significant effects or critical hazards. Short term exposure Potential delayed effects : No known significant effects or critical hazards. Potential immediate effects : No known significant effects or critical hazards. Long term exposure Potential delayed effects : No known significant effects or critical hazards. There is no data available. There is no data available. There is no data available. There is no data available. There is no data available. There is no data available. There is no data available. Dermal contact. Eye contact. Inhalation. Ingestion. 7/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 11. Toxicological information Fertility effects : No known significant effects or critical hazards. Numerical measures of toxicity Acute toxicity estimates There is no data available. Section 12. Ecological information Bioaccumulative potential Other adverse effects : No known significant effects or critical hazards. Toxicity Zinc Alkyldithiophosphate Acute EC50 1 to 5 mg/L Algae 96 hours Acute EC50 1 to 1.5 mg/L Crustaceans 48 hours Chronic LC50 1 to 5 mg/L Fish 96 hours Product/ingredient name SpeciesResult Exposure Persistence and degradability Soil/water partition coefficient (KOC) : There is no data available. Mobility in soil There is no data available. There is no data available. Section 13. Disposal considerations The generation of waste should be avoided or minimized wherever possible. Disposal of this product, solutions and any by-products should comply with the requirements of environmental protection and waste disposal legislation and any regional local authority requirements. Dispose of surplus and non-recyclable products via a licensed waste disposal contractor. Waste should not be disposed of untreated to the sewer unless fully compliant with the requirements of all authorities with jurisdiction. Waste packaging should be recycled. Incineration or landfill should only be considered when recycling is not feasible. This material and its container must be disposed of in a safe way. Care should be taken when handling empty containers that have not been cleaned or rinsed out. Empty containers or liners may retain some product residues. Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers. :Disposal methods 8/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 14. Transport information - - - - - - - Not regulated. - - Not regulated. Not regulated. - - - DOT Classification IMDG IATA UN number UN proper shipping name Transport hazard class(es) Packing group Additional information Environmental hazards Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code No. No. No. Transport within user?s premises: always transport in closed containers that are upright and secure. Ensure that persons transporting the product know what to do in the event of an accident or spillage. : Not available. : Section 15. Regulatory information U.S. Federal regulations Clean Water Act (CWA) 307: Zinc Alkyldithiophosphate : Clean Air Act Section 112 (b) Hazardous Air Pollutants (HAPs) : Not listed Clean Air Act Section 602 Class I Substances : Not listed Clean Air Act Section 602 Class II Substances : Not listed DEA List I Chemicals (Precursor Chemicals) : Not listed DEA List II Chemicals (Essential Chemicals) : Not listed TSCA 8(a) PAIR: Zinc Alkyldithiophosphate TSCA 8(a) CDR Exempt/Partial exemption: Not determined United States inventory (TSCA 8b): All components are listed or exempted. SARA 302/304 SARA 304 RQ : Not applicable. No products were found. Composition/information on ingredients 9/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 15. Regulatory information None of the components are listed. No products were found. Massachusetts : SARA 313 Product name CAS number % SARA 313 notifications must not be detached from the SDS and any copying and redistribution of the SDS shall include copying and redistribution of the notice attached to copies of the SDS subsequently redistributed. Zinc Alkyldithiophosphate 68649-42-3 1 - 5 Zinc Alkyldithiophosphate 68649-42-3 1 - 5 Form R - Reporting requirements Supplier notification California Prop. 65 New York : None of the components are listed. New Jersey : The following components are listed: Distillates (petroleum), hydrotreated heavy naphthenic; Distillates (petroleum), solvent-dewaxed heavy paraffinic; Zinc Alkyldithiophosphate Pennsylvania : The following components are listed: Zinc Alkyldithiophosphate State regulations SARA 311/312 Classification : Immediate (acute) health hazard Zinc Alkyldithiophosphate 1 - 5 No. No. No. Yes. No. Name % Fire hazard Sudden release of pressure Reactive Immediate (acute) health hazard Delayed (chronic) health hazard Composition/information on ingredients Australia inventory (AICS): All components are listed or exempted. China inventory (IECSC): All components are listed or exempted. Japan inventory: Not determined. Korea inventory: All components are listed or exempted. Malaysia Inventory (EHS Register): Not determined. New Zealand Inventory of Chemicals (NZIoC): All components are listed or exempted. Philippines inventory (PICCS): All components are listed or exempted. Taiwan inventory (CSNN): Not determined. International regulations International lists : Chemical Weapons Convention List Schedule I Chemicals : Not listed Chemical Weapons Convention List Schedule II Chemicals : Not listed Chemical Weapons Convention List Schedule III Chemicals : Not listed 10/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com Lucas Red ?N? Tacky NLGI # 2 grease Section 16. Other information History Prepared by : Key to abbreviations : ATE = Acute Toxicity Estimate BCF = Bioconcentration Factor GHS = Globally Harmonized System of Classification and Labelling of Chemicals IATA = International Air Transport Association IBC = Intermediate Bulk Container IMDG = International Maritime Dangerous Goods LogPow = logarithm of the octanol/water partition coefficient MARPOL 73/78 = International Convention for the Prevention of Pollution From Ships, 1973 as modified by the Protocol of 1978. ("Marpol" = marine pollution) UN = United Nations Hazardous Material Information System (U.S.A.) National Fire Protection Association (U.S.A.) Caution: HMIS? ratings are based on a 0-4 rating scale, with 0 representing minimal hazards or risks, and 4 representing significant hazards or risks Although HMIS? ratings are not required on SDSs under 29 CFR 1910.1200, the preparer may choose to provide them. HMIS? ratings are to be used with a fully implemented HMIS? program. HMIS? is a registered mark of the National Paint & Coatings Association (NPCA). HMIS? materials may be purchased exclusively from J. J. Keller (800) 327-6868. The customer is responsible for determining the PPE code for this material. Reprinted with permission from NFPA 704-2001, Identification of the Hazards of Materials for Emergency Response Copyright ?1997, National Fire Protection Association, Quincy, MA 02269. This reprinted material is not the complete and official position of the National Fire Protection Association, on the referenced subject which is represented only by the standard in its entirety. Copyright ?2001, National Fire Protection Association, Quincy, MA 02269. This warning system is intended to be interpreted and applied only by properly trained individuals to identify fire, health and reactivity hazards of chemicals. The user is referred to certain limited number of chemicals with recommended classifications in NFPA 49 and NFPA 325, which would be used as a guideline only. Whether the chemicals are classified by NFPA or not, anyone using the 704 systems to classify chemicals does so at their own risk. Date of issue mm/dd/yyyy Version : : 1 02/15/2014 KMK Regulatory Services Inc. Notice to reader To the best of our knowledge, the information contained herein is accurate. However, neither the above-named supplier, nor any of its subsidiaries, assumes any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards that exist. Health : 0* Flammability :2 Physical hazards : 0 Health : 002 Instability :Flammability : Revised Section(s) : Not applicable. 11/11Tel : +1-888-GHS-7769 (447-7769) / +1-450-GHS-7767 (447-7767)www.kmkregservices.com www.askdrluc.com www.ghssmart.com