SAFETY DATA SHEET 1. Identification Product identifier Bug and Tar Remover Other means of identification FIR No. 167202 Recommended use Bug and Tar Remover Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Supplier Company Name Ford Motor Company Address Attention: MSDS Information, P.O. Box 1899 Dearborn, Michigan 48121 USA Telephone 1-800-392-3673 MSDS Information 1-800-448-2063 This email address is being protected from spambots. You need JavaScript enabled to view it. Emergency telephone numbers Poison Control Center: USA and Canada: 1-800-959-3673 INFOTRAC (Transportation): USA and Canada 1-800-535-5053 2. Hazard(s) identification Category 4Flammable liquidsPhysical hazards Category 1Specific target organ toxicity, repeated exposure Health hazards Category 1Aspiration hazard Category 2Hazardous to the aquatic environment, acute hazard Environmental hazards Category 2Hazardous to the aquatic environment, long-term hazard Not classified.OSHA defined hazards Label elements Signal word Danger Hazard statement Combustible liquid. May be fatal if swallowed and enters airways. Causes damage to organs through prolonged or repeated exposure. Toxic to aquatic life. Toxic to aquatic life with long lasting effects. Precautionary statement Prevention Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not breathe mist or vapor. Wash thoroughly after handling. Do not eat, drink or smoke when using this product. Avoid release to the environment. Wear protective gloves/eye protection/face protection. Response If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. Get medical advice/attention if you feel unwell. In case of fire: Use appropriate media to extinguish. Collect spillage. Storage Store in a well-ventilated place. Keep cool. Store locked up. Disposal Dispose of contents/container in accordance with local/regional/national/international regulations. Hazard(s) not otherwise classified (HNOC) May irritate eyes and skin. May cause irritation of respiratory tract. May be harmful if absorbed through skin. Supplemental information None. FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 1 / 8 3. Composition/information on ingredients Mixtures CAS number %Chemical name Common name and synonyms 64742-47-8Distillates (petroleum), hydrotreated light 50 - < 60 64742-94-5Solvent naphtha (petroleum), heavy arom. 10 - < 20 8052-41-3STODDARD SOLVENT 10 - < 20 Specific chemical identity and/or exact percentage (concentration) of composition has been withheld as a trade secret. 4. First-aid measures Inhalation Move to fresh air. Call a physician if symptoms develop or persist. Skin contact Wash off with soap and water. Get medical attention if irritation develops and persists. Eye contact Rinse with water. Get medical attention if irritation develops and persists. Ingestion Call a physician or poison control center immediately. Rinse mouth thoroughly. Do not induce vomiting. If vomiting occurs, keep head low so that stomach content doesn't get into the lungs. Most important symptoms/effects, acute and delayed Diarrhea. Dizziness. Headache. Nausea, vomiting. Aspiration may cause pulmonary edema and pneumonitis. Direct contact with eyes may cause temporary irritation. Prolonged exposure may cause chronic effects. Indication of immediate medical attention and special treatment needed Provide general supportive measures and treat symptomatically. Keep victim under observation. Symptoms may be delayed. General information If you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. 5. Fire-fighting measures Suitable extinguishing media Alcohol resistant foam. Water fog. Dry chemical powder. Dry chemicals. Carbon dioxide (CO2). Unsuitable extinguishing media Do not use water jet as an extinguisher, as this will spread the fire. Specific hazards arising from the chemical The product is combustible, and heating may generate vapors which may form explosive vapor/air mixtures. During fire, gases hazardous to health may be formed. Upon decomposition, this product emits carbon monoxide, carbon dioxide and/or low molecular weight hydrocarbons. Special protective equipment and precautions for firefighters Self-contained breathing apparatus and full protective clothing must be worn in case of fire. Fire fighting equipment/instructions In case of fire and/or explosion do not breathe fumes. Move containers from fire area if you can do so without risk. Cool containers exposed to heat with water spray and remove container, if no risk is involved. Specific methods Use standard firefighting procedures and consider the hazards of other involved materials. General fire hazards Combustible liquid. 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate protective equipment and clothing during clean-up. Avoid contact with eyes, skin, and clothing. Do not breathe mist or vapor. Ensure adequate ventilation. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS. FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 2 / 8 Methods and materials for containment and cleaning up Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. The product is immiscible with water and will spread on the water surface. Large Spills: Stop the flow of material, if this is without risk. Use water spray to reduce vapors or divert vapor cloud drift. Dike the spilled material, where this is possible. Cover with plastic sheet to prevent spreading. Use a non-combustible material like vermiculite, sand or earth to soak up the product and place into a container for later disposal. Prevent product from entering drains. Following product recovery, flush area with water. Small Spills: Absorb with earth, sand or other non-combustible material and transfer to containers for later disposal. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. Environmental precautions Avoid release to the environment. Prevent further leakage or spillage if safe to do so. Avoid discharge into drains, water courses or onto the ground. Inform appropriate managerial or supervisory personnel of all environmental releases. 7. Handling and storage Precautions for safe handling Keep away from open flames, hot surfaces and sources of ignition. Do not breathe mist or vapor. Avoid contact with eyes. Avoid prolonged or repeated contact with skin. Avoid prolonged exposure. When using, do not eat, drink or smoke. Use only in well-ventilated areas. Wear appropriate personal protective equipment. Wash hands thoroughly after handling. Avoid release to the environment. Observe good industrial hygiene practices. Conditions for safe storage, including any incompatibilities Store locked up. Keep away from heat and sources of ignition. Store in a cool, dry place out of direct sunlight. Store in original tightly closed container. Store in a well-ventilated place. Keep in an area equipped with sprinklers. Store away from incompatible materials (see Section 10 of the SDS). 8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) ValueComponents Type PEL 400 mg/m3Solvent naphtha (petroleum), heavy arom. (CAS 64742-94-5) 100 ppm PEL 2900 mg/m3STODDARD SOLVENT (CAS 8052-41-3) 500 ppm US. ACGIH Threshold Limit Values ValueComponents Type TWA 100 ppmSTODDARD SOLVENT (CAS 8052-41-3) US. NIOSH: Pocket Guide to Chemical Hazards ValueComponents Type TWA 100 mg/m3Distillates (petroleum), hydrotreated light (CAS 64742-47-8) TWA 400 mg/m3Solvent naphtha (petroleum), heavy arom. (CAS 64742-94-5) 100 ppm Ceiling 1800 mg/m3STODDARD SOLVENT (CAS 8052-41-3) TWA 350 mg/m3 Biological limit values No biological exposure limits noted for the ingredient(s). Appropriate engineering controls Use adequate ventilation to control airborne concentrations below the exposure limits/guidelines. If user operations generate a vapor, dust and/or mist, use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below the recommended exposure limits/guidelines. FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 3 / 8 Individual protection measures, such as personal protective equipment Eye/face protection Wear safety glasses with side shields (or goggles). Skin protection Hand protection Suitable chemical protective gloves should be worn when the potential exists for prolonged or repeated skin exposure. The choice of an appropriate glove does not only depend on its material but also on other quality features and is different from one producer to the other. Use protective gloves made of: Neoprene. Polyvinyl chloride (PVC). Rubber gloves. Other Wear suitable protective clothing. Wear appropriate chemical resistant clothing if applicable. Respiratory protection If engineering controls do not maintain airborne concentrations below recommended exposure limits (where applicable) or to an acceptable level (in countries where exposure limits have not been established), an approved respirator must be worn. If engineering controls do not maintain airborne concentrations to a level which is adequate to protect worker health, an approved respirator must be worn. Respirator selection, use and maintenance should be in accordance with the requirements of OSHA Respiratory Protection Standard 29 CFR 1910.134 and/or Canadian Standard CSA Z94.4. Thermal hazards Wear appropriate thermal protective clothing, when necessary. General hygiene considerations When using do not smoke. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. 9. Physical and chemical properties Appearance Physical state Liquid. Form Liquid. Color Colorless to light yellow. Odor Hydrocarbon-like. Odor threshold Not available. pH Not available. Melting point/freezing point Not available. Initial boiling point and boiling range Not available. Flash point 174.7 ?F (79.3 ?C) ASTM D93 Evaporation rate < 1 (BuAc=1) Flammability (solid, gas) Not applicable. Upper/lower flammability or explosive limits Flammability limit - lower (%) Not available. Flammability limit - upper (%) Not available. Explosive limit - lower (%) Not available. Explosive limit - upper (%) Not available. Vapor pressure Not available. Vapor density Not available. Relative density 0.8 Relative density temperature -13 ?F (-25 ?C) Solubility(ies) Solubility (water) INSOLUBLE Partition coefficient (n-octanol/water) Not available. Auto-ignition temperature Not available. Decomposition temperature Not available. Viscosity Not available. Other information Kinematic viscosity 18 cSt FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 4 / 8 Kinematic viscosity temperature 104 ?F (40 ?C) VOC (Weight %) 40 % CAM310 10. Stability and reactivity Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport. Chemical stability Material is stable under normal conditions. Possibility of hazardous reactions No dangerous reaction known under conditions of normal use. Conditions to avoid Avoid heat, sparks, open flames and other ignition sources. Avoid temperatures exceeding the flash point. Contact with incompatible materials. Incompatible materials Strong oxidizing agents. Hazardous decomposition products Upon decomposition, this product emits carbon monoxide, carbon dioxide and/or low molecular weight hydrocarbons. 11. Toxicological information Information on likely routes of exposure Inhalation May cause damage to organs through prolonged or repeated exposure by inhalation. May cause irritation to the respiratory system. Prolonged inhalation may be harmful. Skin contact Harmful if absorbed through skin. May be irritating to the skin. Eye contact Direct contact with eyes may cause temporary irritation. Ingestion Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious chemical pneumonia. Symptoms related to the physical, chemical and toxicological characteristics Diarrhea. Headache. Dizziness. Nausea, vomiting. Aspiration may cause pulmonary edema and pneumonitis. Information on toxicological effects Acute toxicity May be fatal if swallowed and enters airways. Species Calculated/Test ResultsComponents Solvent naphtha (petroleum), heavy arom. (CAS 64742-94-5) LC50 Rat Inhalation Acute 61 mg/l, 4 Hours LD50 Rat Oral > 25 ml/kg Skin corrosion/irritation Prolonged skin contact may cause temporary irritation. Serious eye damage/eye irritation Direct contact with eyes may cause temporary irritation. Respiratory or skin sensitization Respiratory sensitization Not a respiratory sensitizer. Skin sensitization This product is not expected to cause skin sensitization. Germ cell mutagenicity No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. Reproductive toxicity This product is not expected to cause reproductive or developmental effects. Specific target organ toxicity - single exposure Not classified. Specific target organ toxicity - repeated exposure Central nervous system. Causes damage to organs through prolonged or repeated exposure. Aspiration hazard May be fatal if swallowed and enters airways. Chronic effects Causes damage to organs through prolonged or repeated exposure. Prolonged inhalation may be harmful. FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 5 / 8 12. Ecological information Ecotoxicity Toxic to aquatic life with long lasting effects. Ecotoxicity SpeciesComponents Calculated/Test Results Distillates (petroleum), hydrotreated light (CAS 64742-47-8) Aquatic LC50Fish 2.9 mg/l, 96 hoursRainbow trout,donaldson trout (Oncorhynchus mykiss) Solvent naphtha (petroleum), heavy arom. (CAS 64742-94-5) Aquatic EC50Crustacea 2.7 - 5.1 mg/l, 48 hoursWater flea (Daphnia pulex) LC50Fish 8.8 mg/l, 96 hoursRainbow trout,donaldson trout (Oncorhynchus mykiss) 8.8 mg/l, 96 hours Persistence and degradability No data is available on the degradability of this product. Bioaccumulative potential Partition coefficient n-octanol / water (log Kow) STODDARD SOLVENT 3.16 - 7.15 Mobility in soil No data available. Other adverse effects No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. 13. Disposal considerations Disposal instructions Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Do not allow this material to drain into sewers/water supplies. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of contents/container in accordance with local/regional/national/international regulations. Local disposal regulations Dispose in accordance with all applicable regulations. Hazardous waste code The waste code should be assigned in discussion between the user, the producer and the waste disposal company. Waste from residues / unused products Dispose of in accordance with local regulations. Empty containers or liners may retain some product residues. This material and its container must be disposed of in a safe manner (see: Disposal instructions). Contaminated packaging Empty containers should be taken to an approved waste handling site for recycling or disposal. Since emptied containers may retain product residue, follow label warnings even after container is emptied. 14. Transport information DOT Not regulated as dangerous goods. IATA Not regulated as dangerous goods. IMDG Not regulated as dangerous goods. Not established.Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code 15. Regulatory information US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 6 / 8 TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. CERCLA Hazardous Substance List (40 CFR 302.4) Not listed. SARA 304 Emergency release notification Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - Yes Delayed Hazard - Yes Fire Hazard - Yes Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance Not listed. SARA 311/312 Hazardous chemical No SARA 313 (TRI reporting) Not regulated. Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Not regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130) Not regulated. Safe Drinking Water Act (SDWA) Not regulated. US state regulations US. California Controlled Substances. CA Department of Justice (California Health and Safety Code Section 11100) Not listed. US. Massachusetts RTK - Substance List Distillates (petroleum), hydrotreated light (CAS 64742-47-8) Solvent naphtha (petroleum), heavy arom. (CAS 64742-94-5) STODDARD SOLVENT (CAS 8052-41-3) US. New Jersey Worker and Community Right-to-Know Act Distillates (petroleum), hydrotreated light (CAS 64742-47-8) Solvent naphtha (petroleum), heavy arom. (CAS 64742-94-5) STODDARD SOLVENT (CAS 8052-41-3) US. Pennsylvania Worker and Community Right-to-Know Law Distillates (petroleum), hydrotreated light (CAS 64742-47-8) STODDARD SOLVENT (CAS 8052-41-3) US. Rhode Island RTK Not regulated. US. California Proposition 65 WARNING: This product contains a chemical known to the State of California to cause cancer and birth defects or other reproductive harm. International Inventories All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. 16. Other information, including date of preparation or last revision Issue date 05-15-2015 Version # 01 HMIS? ratings Health: 1 Flammability: 2 Physical hazard: 0 FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 7 / 8 NFPA ratings Health: 2 Flammability: 2 Instability: 0 Preparation Information and Disclaimer This document was prepared by FCSD-Toxicology, Ford Motor Company, Diagnostic Service Center II, 1800 Fairlane Drive, Allen Park, MI 48101, USA, based in part on information provided by the manufacturer. The information on this data sheet represents our current data and is accurate to the best of our knowledge as to the proper handling of this product under normal conditions and in accordance with the application specified on the packaging and/or technical guidance literature. Any other use of the product which involves using the product in combination with any other product or any other process is the responsibility of the user. To the extent that there are any differences between this product?s Safety Data Sheet (SDS) and the consumer packaged product labels, the SDS should be followed. Part number(s) ZC-42 FIR No.: 167202 SDS US Issue Date: 05-15-2015 Version: 01 8 / 8