Safety Data Sheet FVP TRANS STOP LEAK 12/12OZ Page 1 of 1 I. PRODUCT AND COMPANY IDENTIFICATION PART#TSC-12 Product Name: FVP TRANS STOP LEAK 12/12OZ Product Code: FV800177 Emergency Phone: (800) 424-9300 (202) 483-7616 (CHEMTREC) Poison Control Center: (800) 222-1222 Company: Factory Motor Parts 1380 Corporate Center Curve, Suite 200 Eagan, MN 55121 Information Phone: (866) 387-3343 Revision Number: 2 II. HAZARDS IDENTIFICATION Routes of Entry: Eye contact, Ingestion, Inhalation, Skin contact Chemical Interactions: No chemical interaction known to affect toxicity. Conditions Aggravated by Exposure: Personnel with pre-existing skin disorders should avoid contact with this product. Acute Health Effects: Inhalation Irritation: Can cause moderate respiratory irritation, dizziness, weakness, fatigue, nausea and headache. Skin Contact: Can cause moderate skin irritation, defatting, and dermatitis. Not likely to cause permanent damage. Skin Absorption: Minimal hazard in normal industrial use. May cause gastrointestinal discomfort. Eye Contact: Can cause moderate irritation, tearing and reddening, but not likely to permanently injure eye tissue. Ingestion Irritation: Irritating to mouth, throat, and stomach. Can cause abdominal discomfort, nausea, vomiting and diarrhea. Chronic Health Effects: Carcinogenicity: Not a carcinogen according to NTP, IARC, or OSHA. Reproductive Toxicity: No data available to indicate product or any components present at greater than 0.1% may cause birth defects. Mutagenicity: No data available to indicate product or any components present at greater than 0.1% is mutagenic or genotoxic. Safety Data Sheet FVP TRANS STOP LEAK 12/12OZ Page 2 of 2 HMIS Ratings: NFPA Ratings: Health: 2 Health: 1 Fire: 1 Fire: 1 Reactivity: 0 Reactivity: 0 PPE: B KEY: 0 - Least 1 - Slight 2 - Moderate 3 - High 4 ? Extreme III. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name % CAS # OSHA Exposure Limits Petroleum distillates, hydrotreated heavy paraffinic 90 - 99 64742-54-7 No PEL Petroleum distillates, hydrotreated middle 1 - 5 64742-46-7 No PEL 3-(Decyloxy)tetrahydrothiophene 1,1-dioxide 0.1 - 1 18760-44-6 No PEL Components not listed are not physical or health hazards as defined in 29 CFR 1910.1200 (Hazard Communication Standard). IV. FIRST-AID MEASURES Inhalation: Remove to fresh air. If breathing is difficult, have a trained individual administer oxygen. If not breathing, give artificial respiration and have a trained individual administer oxygen and get medical attention immediately. Eyes: Flush eyes with plenty of water for at least 20 minutes retracting eyelids often. Tilt the head to prevent chemical from transferring to the uncontaminated eye. Get immediate medical attention. Skin Contact: Wash with soap and water. Remove contaminated clothing and launder. Get medical attention if irritation develops or persists. Ingestion: Do not induce vomiting and seek medical attention immediately. Provide medical care provider with this MSDS. Notes to Doctor: No additional first aid information available. V. FIRE FIGHTING MEASURES Flammability Summary: Combustible at elevated temperatures Extinguishing Media: Use alcohol resistant foam, carbon dioxide, or dry chemical when fighting fires. Water or foam may cause frothing if liquid is burning but it still may be a useful extinguishing agent if carefully applied to the surface of the fire. Do not direct a stream of water into the hot burning liquid. Fire and/or Explosion Hazards: Material may be ignited only if preheated to temperatures above the high flash point, for example in a fire. Fire Fighting Methods and Protection: Do not enter fire area without proper protection including self- contained breathing apparatus and full protective equipment. Use methods for the surrounding fire. Hazardous Combustion Products: Carbon dioxide, Carbon monoxide, Smoke Flash Point: 193 ?C (379 ?F ) Autoignition Temperature: No data. Safety Data Sheet FVP TRANS STOP LEAK 12/12OZ Page 3 of 3 VI. ACCIDENTAL RELEASE MEASURES Personal Precautions and Equipment: Exposure to the spilled material may be irritating or harmful. Follow personal protective equipment recommendations found in Section 8 of this MSDS. Additional precautions may be necessary based on special circumstances created by the spill including; the material spilled, the quantity of the spill, the area in which the spill occurred. Also consider the expertise of employees in the area responding to the spill. Methods for Clean-up: Prevent the spread of any spill to minimize harm to human health and the environment if safe to do so. Wear complete and proper personal protective equipment following the recommendation of Section 8 at a minimum. Dike with suitable absorbent material like granulated clay. Dispose of in regular trash as product is not considered a hazardous waste. Used fluid should be disposed of at a recycling center. Do not flush to sewer. VII. HANDLING AND STORAGE Handling Precautions: Harmful or irritating material. Avoid contacting and avoid breathing the material. Use only in a well ventilated area. Empty containers may retain product residues/ vapors. Use proper bonding and grounding during bulk product transfer. Storage Conditions: Store in a cool dry ventilated location. Isolate from incompatible materials and conditions. Keep container(s) closed. Do not expose to extreme temperatures or flames. VIII. EXPOSURE CONTROLS/PERSONAL PROTECTION Engineering Controls: No exposure limits exist for the constituents of this product. Use local exhaust ventilation or other engineering controls to minimize exposures and maintain operator comfort. Respiratory Protection: Respiratory protection may be required to avoid overexposure when handling this product. General or local exhaust ventilation is the preferred means of protection. Use a respirator if general room ventilation is not available or sufficient to eliminate symptoms. Respirator Type(s): None required where adequate ventilation is provided. If airborne concentrations are above the applicable exposure limits, use NIOSH/MSHA approved respiratory protection. Eye Protection: Wear chemically resistant safety glasses with side shields when handling this product. Do not wear contact lenses. Skin Protection: Wear protective gloves. Inspect gloves for chemical break-through and replace at regular intervals. Clean protective equipment regularly. Wash hands and other exposed areas with mild soap and water before eating, drinking, and when leaving work. Gloves: Neoprene, Nitrile Control Parameters: Chemical Name ACGIH TLV-TWA ACGIH STEL IDLH OSHA STEL Petroleum distillates, hydrotreated heavy paraffinic No TLV No STL No IDLH No STEL Petroleum distillates, hydrotreated middle No TLV No STL No IDLH No STEL 3-(Decyloxy)tetrahydrothiophene 1,1- dioxide No TLV No STL No IDLH No STEL Safety Data Sheet FVP TRANS STOP LEAK 12/12OZ Page 4 of 4 IX. PHYSICAL AND CHEMICAL PROPERTIES Physical State: Liquid Color: Red Odor: Mild Viscosity: 7.14 cSt @100?C Solubility in Water: Negligible; 0-1% Evaporation Rate: No data. Vapor Pressure: No data. Boiling Point (?C): No data. Specific Gravity: 0.86 Density: 7.18 Flash Point (?C): 193 Flash Point Method: COC Upper Flammability Limit, % in air: Unknown Lower Flammability Limit, % in air: Unknown X. STABILITY AND REACTIVITY Stability: Stable under normal conditions. Conditions to Avoid: Temperatures above the high flash point of this combustible material in combination with sparks, open flames, or other sources of ignition. Materials to Avoid: Strong oxidizing agents Hazardous Decomp. Products: Carbon monoxide, sulfur oxides, aldehydes, and other petroleum decomposition products in the case of incomplete combustion. Oxides of nitrogen, phosphorus, calcium, copper, magnesium, sodium, and hydrogen sulfide may also be present. Hazardous Polymerization: Will not occur. XI. TOXICOLOGICAL INFORMATION Acute Toxicity: Ingestion: Lubricating oils are generally no more than slightly toxic if swallowed. Inhalation: Harmful! Can cause systemic damage (see "Target Organs"). Absorption: Minimal hazard in normal industrial use. May cause gastrointestinal discomfort. Eyes (Draize score): No data. Skin (Draize score): No data. Component Toxicology Data (NIOSH): Chemical Name CAS Number LD50/LC50 Petroleum distillates, hydrotreated middle 64742-46-7 Inhalation LC50 Rat 4.6 mg/L 4 h; Oral LD50 Rat 7400 mg/kg; Dermal LD50 Rabbit >2000 mg/kg Thiophene, tetrahydro-3-(decyloxy)- , 1,1-dioxide 18760-44-6 Oral LD50 Rat >10 mL/kg XII. ECOLOGICAL INFORMATION Overview: Moderate ecological hazard. This product may be dangerous to plants and/or wildlife. Mobility: This material is expected to have essentially no mobility in soil. It absorbs strongly to most soil types. Persistence: No data. Bioconcentration: Bioconcentration is not expected to occur. Degradability: Biodegrades slowly. Safety Data Sheet FVP TRANS STOP LEAK 12/12OZ Page 5 of 5 Toxicity to Aquatic Invertebrates: CAS Number Results Petroleum distillates, hydrotreated heavy paraffinic 64742-54-7 48 Hr EC50 Daphnia magna: >1000 mg/L Petroleum distillates, hydrotreated light naphthenic 64742-53-6 48 Hr EC50 Daphnia magna: >1000 mg/L Toluene 108-88-3 48 Hr EC50 Daphnia magna: 5.46 - 9.83 mg/L [Static]; 48 Hr EC50 Daphnia magna: 11.5 mg/L Toluene 108-88-3 96 Hr EC50 Pseudokirchneriella subcapitata: >433 mg/L; 72 Hr EC50 Pseudokirchneriella subcapitata: 12.5 mg/L [static] Toxicity to Fish: CAS Number Results Petroleum distillates, hydrotreated heavy paraffinic 64742-54-7 96 Hr LC50 Oncorhynchus mykiss: >5000 mg/L Petroleum distillates, hydrotreated middle 64742-46-7 96 Hr LC50 Pimephales promelas: 35 mg/L [flow- through]; 96 Hr LC50 Pimephales promelas: >10000 mg/L [static] XIII. DISPOSAL CONSIDERATIONS Disposal of Packaging: Recycle containers whenever possible. Disposal Methods: Dispose of according to Federal, State, Local, or Provincial regulations. Recycle used oil. XIV. TRANSPORTATION INFORMATION Not classified as hazardous for transport (DOT, TDG, IMO/IMDG, IATA/ICAO). XV. REGULATORY INFORMATION TSCA Status: All components of this material are on the US TSCA Inventory or are exempt. NAFTA Tariff Code: 2710.11.0000 State Restrictions: ND WHMIS: Uncontrolled product according to WHMIS classification criteria Chemical Name CAS Number Regulation % Range None Listed. CERCLA RQ Toluene 108-88-3 SARA 313 0.01 - 0.1 None Listed. SARA 302-EHS None Listed. TSCA 12b export notification None Listed. CA Prop 65 ? Cancer Toluene 108-88-3 CA Prop 65 - Dev. Toxicity 0.01 - 0.1 Toluene 108-88-3 CA Prop 65 - Reprod ?fem 0.01 - 0.1 Hydrotreated middle distillate (petroleum) 64742-46-7 Canadian WHMIS List 1 - 5 None Listed. Massachusetts RTK List None Listed. New Jersey RTK List None Listed. Pennsylvania RTK List None Listed. Minnesota Hazardous Substance List None Listed. Rhode Island Hazardous Substance List Safety Data Sheet FVP TRANS STOP LEAK 12/12OZ Page 6 of 6 Consumer Product Safety Improvement Act of 2008 General Conformity Certification: This product has been evaluated and certified to be labeled and packaged in compliance with the applicable provisions of the Federal Hazardous Substance Act as stated in 16 CFR 1500 and enforced by the Consumer Product Safety Commission, and where applicable the products that require Child Resistant Closures are packaged in accordance with the Poison Prevention Packaging Act as stated in 16 CFR 1700 and enforced by the Consumer Product Safety Commission. All closures have been tested in accordance with the latest protocols. No other testing is required to certify compliance with the above. The date of manufacture is stamped on the product container. XVI. ADDITIONAL INFORMATION Superseded by: 2011-03-09 11:48:18 Revision Date: 2012-01-09 09:28:14 Created by: HAZEMS Disclaimer: This material safety data sheet and the information it contains is offered to you in good faith as accurate. We have reviewed any information contained in the data sheet which we have received from outside sources and we believe the information to be correct, but cannot guarantee its accuracy or completeness. Health and safety precautions in this data sheet may not be adequate for all individuals and/or situations. It is the user's obligation to evaluate and use this product in a safe manner and to comply with all applicable laws and regulations. No statement made in this data sheet shall be construed as permission or recommendation for the use of any product in a manner that might infringe existing patents. No warranty is made, either expressed or implied.