TURBO POWER ALL SEASON Antifreeze/Coolant Safety Data Sheet Product Identifier TURBO POWER ALL SEASON Antifreeze/Coolant Other Means of Identification 86-249 Recochem Inc., 850 Montee de Liesse, Montreal, QC, H4T 1P4, Compliance and Regulatory Department, 905-878-5544, www.recochem.com Recommended Use SDS No. Emergency Phone No. SECTION 1. IDENTIFICATION Manufacturer / Supplier Please refer to Product label. 0749 CANUTEC, 613-996-6666, 24 Hours Restrictions on Use None known. GHS Label Elements SECTION 2. HAZARDS IDENTIFICATION Signal Word: Danger Hazard Statement(s): H302 Harmful if swallowed. H360 May damage the unborn child if inhaled, following skin contact and/or if swallowed. H360 May damage fertility if inhaled, following skin contact and/or if swallowed. Precautionary Statement(s): Prevention: P201 Obtain special instructions before use. P202 Do not handle until all safety precautions have been read and understood. P264 Wash hands and skin thoroughly after handling. P270 Do not eat, drink or smoke when using this product. P280 Wear protective gloves/protective clothing/eye protection/face protection. Response: P301 + P312 IF SWALLOWED: Call a POISON CENTRE/doctor if you feel unwell. P330 Rinse mouth. P308 + P313 IF exposed or concerned: Get medical advice/attention. Storage: Store in a well ventilated place. Keep cool. Keep container tightly closed. Store locked up. Disposal: Dispose of contents/container in accordance with applicable regional, national and local laws and regulations. GHS Classification Acute toxicity (Oral) - Category 4; Reproductive Toxicity - Category 1B SDS No.: Date of Preparation: 0749 Page of 0801 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant Storage: Store in a well ventilated place. Keep cool. Keep container tightly closed. Store locked up. Disposal: Dispose of contents/container in accordance with applicable regional, national and local laws and regulations. Other Hazards None known. SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No. Other Identifiers% Mixture: Ethylene glycol 107-21-1 60-100 Sodium Salt of Boron Acid CBI* Notes CBI = Confidential Business Information. The specific chemical identity and/or exact percentage of composition (concentration) has been withheld as a trade secret. Inhalation Remove source of exposure or move to fresh air. Call a Poison Centre or doctor if you feel unwell or are concerned. Skin Contact Take off contaminated clothing, shoes and leather goods (e.g. watchbands, belts). Wash gently and thoroughly with lukewarm, gently flowing water and mild soap for 5 minutes. Call a Poison Centre or doctor if you feel unwell or are concerned. Clean clothing, shoes and leather goods. Eye Contact If eye irritation persists, get medical advice/attention. Immediately rinse the contaminated eye(s) with lukewarm, gently flowing water for 15-20 minutes, while holding the eyelid(s) open. Ingestion Rinse mouth with water. Call a Poison Centre or doctor if you feel unwell or are concerned. Special Instructions The signs and symptoms in ethylene glycol poisoning are those of metabolic acidosis, central nervous system depression and kidney injury. Clinical chemistry may reveal anion-gap metabolic acidosis and uremia. Treatment with ethanol to inhibit the metabolism of glycol to oxalate.Early administration of ethanol may counter the toxic effects of ethylene glycol (cardiopulmonary effects attributed to metabolic acidosis and renal damage). Hemodialysis or peritoneal dialysis have been of benefit. Pre-existing respiratory and skin disorders may be aggravated by over-exposure to this product. Treat symptomatically and supportively. SECTION 4. FIRST-AID MEASURES First-aid Measures Immediate Medical Attention and Special Treatment Target Organs Digestive system, nervous system, heart, digestive system, kidneys, skin. Most Important Symptoms and Effects, Acute and Delayed If swallowed: There are 3 stages of effects, which can overlap. Early symptoms can include upset stomach, slurred speech, clumsiness, drowsiness, and convulsions. Second stage symptoms can include rapid heartbeat and breathing, bluish lips and skin, fluid in the lungs and heart failure. In the last stage, there can be kidney stones and kidney damage with lower back pain, and increased then decreased urine production. There may be delayed nervous system effects such as paralysis of the face, clumsiness, impaired hearing and blurred vision. Death can occur at any stage. SDS No.: Date of Preparation: 0749 Page of 0802 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant The signs and symptoms in ethylene glycol poisoning are those of metabolic acidosis, central nervous system depression and kidney injury. Clinical chemistry may reveal anion-gap metabolic acidosis and uremia. Treatment with ethanol to inhibit the metabolism of glycol to oxalate.Early administration of ethanol may counter the toxic effects of ethylene glycol (cardiopulmonary effects attributed to metabolic acidosis and renal damage). Hemodialysis or peritoneal dialysis have been of benefit. Pre-existing respiratory and skin disorders may be aggravated by over-exposure to this product. Treat symptomatically and supportively. Medical Conditions Aggravated by Exposure Dermatitis. Extinguishing Media Suitable Extinguishing Media Carbon dioxide, dry chemical powder or appropriate foam. Unsuitable Extinguishing Media None known. Specific Hazards Arising from the Chemical Can ignite if strongly heated. In a fire, the following hazardous materials may be generated: irritating chemicals. Special Protective Equipment and Precautions for Fire-fighters Review Section 6 (Accidental Release Measures) for important information on responding to leaks/spills. See Skin Protection in Section 8 (Exposure Controls/Personal Protection) for advice on suitable chemical protective materials. SECTION 5. FIRE-FIGHTING MEASURES Personal Precautions, Protective Equipment, and Emergency Procedures Use the personal protective equipment recommended in Section 8 of this safety data sheet. Environmental Precautions Do not allow into any sewer, on the ground or into any waterway. Methods and Materials for Containment and Cleaning Up Stop leak if without risk. Move containers from spill area. Approach release from upwind. Prevent entry into sewers, water courses, basements or confined areas. Wash spillages into an effluent treatment plant or proceed as follows. Contain and collect spillage with non-combustible, absorbent material e.g. sand, earth, vermiculite or diatomaceous earth and place in container for disposal according to local regulations (see section 13). Use spark-proof tools and explosion-proof equipment. Dispose of via a licensed waste disposal contractor. Contaminated absorbent material may pose the same hazard as the spilled product. Note: see section 1 for emergency contact information and section 13 for waste disposal. SECTION 6. ACCIDENTAL RELEASE MEASURES Precautions for Safe Handling Put on appropriate personal protective equipment (see section 8). Eating, drinking and smoking should be prohibited in areas where this material is handled, stored and processed. Workers should wash hands and face before eating, drinking and smoking. Do not ingest. Avoid contact with eyes, skin and clothing. Avoid breathing vapour or mist. Use only with adequate ventilation. Wear appropriate respirator when ventilation is inadequate. Do not enter storage areas and confined spaces unless adequately ventilated. Keep in the original container or an approved alternative made from a compatible material, kept tightly closed when not in use. Store and use away from heat, sparks, open flame or any other ignition source. Use explosion-proof electrical (ventilating, lighting and material handling) equipment. Use non-sparking tools. Take precautionary measures against electrostatic discharges. To avoid fire or explosion, dissipate static electricity during transfer by grounding and bonding containers and equipment before transferring material. Empty containers retain product residue and can be hazardous. Do not reuse container. Conditions for Safe Storage Store in accordance with local regulations. Store in a segregated and approved area. Store in original container protected from direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials (see section 10) and food and drink. Eliminate all ignition sources. Separate from oxidizing materials. Keep container tightly closed and sealed until ready for use. Containers that have been opened must be carefully resealed and kept upright to prevent leakage. Do not store in unlabeled containers. Use appropriate containment to avoid environmental contamination. SECTION 7. HANDLING AND STORAGE SDS No.: Date of Preparation: 0749 Page of 0803 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant Store in accordance with local regulations. Store in a segregated and approved area. Store in original container protected from direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials (see section 10) and food and drink. Eliminate all ignition sources. Separate from oxidizing materials. Keep container tightly closed and sealed until ready for use. Containers that have been opened must be carefully resealed and kept upright to prevent leakage. Do not store in unlabeled containers. Use appropriate containment to avoid environmental contamination. SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION ACGIH TLV? OSHA PEL Chemical Name TWA STEL TWA Ceiling Control Parameters AIHA WEEL 8-hr TWA TWA Ethylene glycol 10 mg/m3 100 mg/m3 Not established 50 ppm Sodium Salt of Boron Acid Not established Not established Not established Not established Appropriate Engineering Controls Individual Protection Measures Skin Protection Respiratory Protection Eye/Face Protection Not normally required if product is used as directed. For non-routine or emergency situations: wear a NIOSH approved air-purifying respirator with an appropriate cartridge. Wear chemical protective clothing e.g. gloves, aprons, boots. Nitrile rubber. Not required but it is good practice to wear safety glasses or chemical safety goggles. The hazard potential of this product is relatively low. General ventilation is usually adequate. Use local exhaust ventilation, if general ventilation is not adequate to control amount in the air. pH Not available Appearance Clear green liquid. Partition Coefficient, n-Octanol/Water (Log Kow) -1.36 at 20 ?C (Ethylene glycol) Odour Not available Vapour Pressure 0.090 mm Hg (0.012 kPa) at 20 ?C (Ethylene glycol) Odour Threshold Not available Vapour Density (air = 1) 2.14 (estimated) Initial Boiling Point/Range 197 ?C (387 ?F) Evaporation Rate < 0.01 Flash Point 111 ?C (232 ?F) (closed cup) (Ethylene glycol) Melting Point/Freezing Point -13 ?C (9 ?F) (Ethylene glycol) (melting); -13 ?C (9 ?F) (Ethylene glycol) (freezing) Relative Density (water = 1) 1.12 - 1.15 at 20 ?C (Ethylene glycol) Upper/Lower Flammability or Explosive Limit 21.6 - 22.0% (Ethylene glycol) (upper); 3.2% (Ethylene glycol) (lower) Solubility Not available in water; Soluble in all proportions in ketones (e.g. acetone). Auto-ignition Temperature 398 ?C (748 ?F) (Ethylene glycol) SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES Not availableDecomposition Temperature Basic Physical and Chemical Properties Flammability (solid, gas) Not applicable SDS No.: Date of Preparation: 0749 Page of 0804 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant Molecular Weight Not available Not availableDecomposition Temperature Viscosity 18.86 mm2/s at 20 ?C (estimated) (kinematic); 21 mPa.s at 20 ?C (estimated) (dynamic) LiquidPhysical State Other Information Chemical Stability Normally stable. Conditions to Avoid None known. Incompatible Materials Slightly reactive or incompatible with the following materials: oxidizing agents (e.g. peroxides), strong acids (e.g. hydrochloric acid), strong bases (e.g. sodium hydroxide). Not corrosive to metals. Hazardous Decomposition Products None known. Possibility of Hazardous Reactions None known. SECTION 10. STABILITY AND REACTIVITY Reactivity Not reactive under normal conditions of use. LC50: Not applicable. LD50 (oral): Not applicable. Skin Corrosion/Irritation May cause moderate or severe irritation based on information for closely related materials. Symptoms include pain, redness, and swelling. Serious Eye Damage/Irritation May cause serious eye irritation based on information for closely related materials. Symptoms include sore, red eyes, and tearing. SECTION 11. TOXICOLOGICAL INFORMATION STOT (Specific Target Organ Toxicity) - Single Exposure Inhalation At high concentrations vapour may cause lung injury, nose and throat irritation. Symptoms may include coughing, shortness of breath, difficult breathing and tightness in the chest. Symptoms may include headache, nausea, dizziness, drowsiness and confusion. LD50 (dermal): Not applicable. Acute Toxicity Skin contact; ingestion. Likely Routes of Exposure Chemical Name LC50 LD50 (oral) LD50 (dermal) Ethylene glycol 2725 mg/m3 (rat) (4-hour exposure) 4700 mg/kg (rat) 9530 mg/kg (rabbit) Sodium Salt of Boron Acid Not available Not available Not available SDS No.: Date of Preparation: 0749 Page of 0805 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant At high concentrations vapour may cause lung injury, nose and throat irritation. Symptoms may include coughing, shortness of breath, difficult breathing and tightness in the chest. Symptoms may include headache, nausea, dizziness, drowsiness and confusion. Skin Absorption At high concentrations may cause Symptoms may include redness, rash, swelling and itching. Ingestion Toxic, can cause death based on information for closely related materials. depression of the central nervous system, and effects on the heart and kidneys. In some cases, there may be delayed effects on the nervous system. There are 3 stages of effects, which can overlap. Early symptoms can include upset stomach, slurred speech, clumsiness, drowsiness, and convulsions. Second stage symptoms can include rapid heartbeat and breathing, bluish lips and skin, fluid in the lungs and heart failure. In the last stage, there can be kidney stones and kidney damage with lower back pain, and increased then decreased urine production. There may be delayed nervous system effects such as paralysis of the face, clumsiness, impaired hearing and blurred vision. Death can occur at any stage. May cause dermatitis. Symptoms may include dry, red, cracked skin (dermatitis). Harmful effects on the kidneys. STOT (Specific Target Organ Toxicity) - Repeated Exposure Respiratory and/or Skin Sensitization Not known to be a respiratory sensitizer. Not known to be a skin sensitizer. Carcinogenicity Development of Offspring If swallowed: at high concentrations animal studies show effects on the offspring. Known to cause: decreased weight. Embryotoxic (late resorptions) teratogenic(external, soft tissue and skeletal defects) may harm the unborn child. (Sodium Salt of Boron Acid) Reproductive Toxicity May cause effects on sexual function and/or fertility. (Sodium Salt of Boron Acid) Germ Cell Mutagenicity Not known to be a mutagen. Interactive Effects No information was located. Other Information TOXIC SUBSTANCE: KEEP AWAY FROM ANIMALS AND SMALL CHILDREN. Sexual Function and Fertility Effects on or via Lactation No information was located. Not known to be an aspiration hazard. Aspiration Hazard Chemical Name IARC ACGIH? NTP OSHA Ethylene glycol Not Listed A4 Not Listed Not Listed Sodium Salt of Boron Acid Not Listed A4 Not Listed Not Listed SECTION 12. ECOLOGICAL INFORMATION Toxicity Chronic Aquatic Toxicity Acute Aquatic Toxicity Chemical Name LC50 Fish EC50 Crustacea ErC50 AquaticPlants ErC50 Algae Ethylene glycol 18500 mg/L (Oncorhynchus mykiss (rainbow trout); 96-hour; fresh water) 74000 mg/L (Daphnia magna (water flea); 24 hr) SDS No.: Date of Preparation: 0749 Page of 0806 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant This product and its degradation products are not expected to bioaccumulate. No information was located. There is no information available. No information was located. Persistence and Degradability Mobility in Soil Other Adverse Effects Bioaccumulative Potential Chronic Aquatic Toxicity Ethylene glycol trout); 96-hour; fresh water) Sodium Salt of Boron Acid Not available Not available Chemical Name NOEC Fish EC50 Fish NOEC Crustacea EC50 Crustacea Ethylene glycol 39140 mg/L (Oncorhynchus mykiss (rainbow trout)) 24000 mg/L (Daphnia magna (water flea)) Sodium Salt of Boron Acid Not available Not available SECTION 13. DISPOSAL CONSIDERATIONS The generation of waste should be avoided or minimized wherever possible. Empty containers or liners may retain some product residues. This material and its container must be disposed of in a safe way. Dispose of surplus and non- recyclable products via a licensed waste disposal contractor. Disposal of this product, solutions and any by-products should at all times comply with the requirements of environmental protection and waste disposal legislation and any regional local authority requirements. Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers. Disposal Methods SECTION 14. TRANSPORT INFORMATION Not regulated under Canadian TDG Regulations. UN No. Proper Shipping Name PackingGroup Transport Hazard Class(es)Regulation 3082 ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID (Ethylene glycol) 9 IIIUS DOT Special Precautions for User Please note: In single containers of 5000 lbs capacity or less this product is exempt from DOT regulations (non regulated). Does not require label or placards. Regulated Quantity (RQ)= 5000 lbs (2268 kg) (as ethylene glycol) For bulk shipments equal to or greater than Regulated Quantity (RQ), please adhere to classification as outlined in DOT Classification section. Transport in Bulk According to Annex II of MARPOL 73/78 and the IBC Code Not applicable SECTION 15. REGULATORY INFORMATION Canada Domestic Substances List (DSL) / Non-Domestic Substances List (NDSL) All ingredients are listed on the DSL/NDSL. USA Safety, Health and Environmental Regulations SDS No.: Date of Preparation: 0749 Page of 0807 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant USA Toxic Substances Control Act (TSCA) Section 8(b) All ingredients are listed on the TSCA Inventory. Additional USA Regulatory Lists California Proposition 65: WARNING: This product contains chemicals known to the State of California to cause birth defects. Additional Information We are committed to uphold the Industry Consumer Ingredient Communication Voluntary Initiative. Please send us your request by visiting our website at www.recochem.com. Ingredients present (intentionally added ingredients) at a concentration of greater than one percent (1%) shall be listed in descending order of predominance. Ingredients present at a concentration of not more than one percent shall be listed but may be disclosed without respect to order of predominance. Disclaimer Notice to reader: To the best of our knowledge, the information contained herein is accurate. However, neither the above named supplier nor any of its subsidiaries assumes any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards that exist. SECTION 16. OTHER INFORMATION SDS Prepared By Compliance and Regulatory Department Phone No. 905-878-5544 SDS No.: Date of Preparation: 0749 Page of 0808 Product Identifier: TURBO POWER ALL SEASON Antifreeze/Coolant