Safety Data Sheet Revision Number: 003.0 Issue date: 02/28/2014 IDH number: 495549 Product name: LOCTITE LB 8423 DIELECTRIC TUNE-UP GREASE known as LOCTITE? DIELECTRIC TUNE-UP G Page 1 of 5 1. PRODUCT AND COMPANY IDENTIFICATION Product name: LOCTITE LB 8423 DIELECTRIC TUNE- UP GREASE known as LOCTITE? DIELECTRIC TUNE-UP G IDH number: 495549 Product type: Lubricant Item number: 37535 Restriction of Use: None identified Region: United States Company address: Contact information: Henkel Corporation One Henkel Way Rocky Hill, Connecticut 06067 Telephone: 860.571.5100 MEDICAL EMERGENCY Phone: Poison Control Center 1-877-671-4608 (toll free) or 1-303-592-1711 TRANSPORT EMERGENCY Phone: CHEMTREC 1-800-424-9300 (toll free) or 1-703-527-3887 Internet: www.henkelna.com 2. HAZARDS IDENTIFICATION EMERGENCY OVERVIEW WARNING: CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE IRRITATION. HAZARD CLASS HAZARD CATEGORY SKIN IRRITATION 2 EYE IRRITATION 2A PICTOGRAM(S) Precautionary Statements Prevention: Wash thoroughly after handling. Wear eye and face protection. Wear protective gloves. Response: IF ON SKIN: Wash with plenty of soap and water. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If skin irritation occurs: Get medical attention. If eye irritation persists: Get medical attention. Take off contaminated clothing. Storage: Not prescribed Disposal: Not prescribed Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of the United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS). See Section 11 for additional toxicological information. 3. COMPOSITION / INFORMATION ON INGREDIENTS Hazardous Component(s) CAS Number Percentage* Silica, amorphous, fumed, crystal-free 112945-52-5 5 - 10 Silicone Resin Proprietary 60 - 100 IDH number: 495549 Product name: LOCTITE LB 8423 DIELECTRIC TUNE-UP GREASE known as LOCTITE? DIELECTRIC TUNE-UP G Page 2 of 5 * Exact percentage is a trade secret. Concentration range is provided to assist users in providing appropriate protections. 4. FIRST AID MEASURES Inhalation: Move to fresh air. If symptoms develop and persist, get medical attention. If breathing is difficult, give oxygen. Get immediate medical attention. Skin contact: Wash with soap and water. If symptoms develop and persist, get medical attention. Eye contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. If eye irritation persists, consult a specialist. Ingestion: Do not induce vomiting. Get medical attention. Symptoms: See Section 11. 5. FIRE FIGHTING MEASURES Extinguishing media: Water spray (fog), foam, dry chemical or carbon dioxide. Special firefighting procedures: Water should be used to cool closed containers to prevent pressure build-up and possible autoignition or explosion when exposed to extreme heat. Wear a self-contained breathing apparatus with a full face piece operated in pressure- demand or other positive pressure mode. Unusual fire or explosion hazards: None Hazardous combustion products: Oxides of carbon. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Ventilate area. Do not allow product to enter sewer or waterways. Clean-up methods: Scrape up spilled material and place in a closed container for disposal. 7. HANDLING AND STORAGE Handling: Avoid contact with eyes, skin and clothing. Use only with adequate ventilation. Storage: Keep away from heat, spark and flame. Keep in a cool, well ventilated area. For information on product shelf life contact Henkel Customer Service at (800) 243-4874. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure controls and protective equipment for each task performed. Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHER Silica, amorphous, fumed, crystal-free 10 mg/m3 TWA Inhalable dust. 3 mg/m3 TWA Respirable fraction. 20 MPPCF TWA 0.8 mg/m3 TWA None None Silicone Resin None None None None IDH number: 495549 Product name: LOCTITE LB 8423 DIELECTRIC TUNE-UP GREASE known as LOCTITE? DIELECTRIC TUNE-UP G Page 3 of 5 Engineering controls: Use local ventilation if general ventilation is insufficient to maintain vapor concentration below established exposure limits. Respiratory protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s). Observe OSHA regulations for respirator use (29 CFR 1910.134). Eye/face protection: Safety goggles or safety glasses with side shields. Skin protection: Chemical resistant, impermeable gloves. Use of Butyl or Nitrile Rubber gloves is recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Liquid Color: Clear Odor: Mild Odor threshold: Not available. pH: Not applicable Vapor pressure: < 5 mm hg (77 ?F (25?C)) Boiling point/range: > 300 ?F (> 148.9 ?C) None Melting point/ range: Not available. Specific gravity: 0.86 Vapor density: Heavier than air. Flash point: > 260 ?C (> 500?F) HST-US D09F; Flash/Fire Point By Cleveland Open Cup Flammable/Explosive limits - lower: Not available. Flammable/Explosive limits - upper: Not available. Autoignition temperature: Not determined Evaporation rate: Not available. Solubility in water: Not available. Partition coefficient (n-octanol/water): More soluble in octanol. VOC content: 0 %; 0 g/l Viscosity: Not available. Decomposition temperature: Not available. 10. STABILITY AND REACTIVITY Stability: Stable at normal conditions. Hazardous reactions: Will not occur. Hazardous decomposition products: Formaldehyde. Oxides of carbon. Incompatible materials: Strong acids and strong bases. Strong oxidizing agents. Reactivity: Not available. Conditions to avoid: Heat, flames, sparks and other sources of ignition. 11. TOXICOLOGICAL INFORMATION Relevant routes of exposure: Ingestion IDH number: 495549 Product name: LOCTITE LB 8423 DIELECTRIC TUNE-UP GREASE known as LOCTITE? DIELECTRIC TUNE-UP G Page 4 of 5 Potential Health Effects/Symptoms Inhalation: When heated to temperatures exceeding 300? F (150? C) in the presence of air, silicones may form formaldehyde vapors. Formaldehyde is a potential cancer hazard and a known skin and respiratory sensitizer. Vapors irritate the eyes, nose and throat. Safe handling conditions may be maintained by keeping formaldehyde vapor concentrations below the OSHA permissible limit. Mist or spray may cause respiratory tract irritation and delayed onset pulmonary edema. Skin contact: Causes skin irritation. Eye contact: Causes serious eye irritation. Ingestion: Not expected under normal conditions of use. Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health Effects Silica, amorphous, fumed, crystal-free None Nuisance dust Silicone Resin None Irritant Hazardous Component(s) NTP Carcinogen IARC Carcinogen OSHA Carcinogen (Specifically Regulated) Silica, amorphous, fumed, crystal-free No No No Silicone Resin No No No 12. ECOLOGICAL INFORMATION Ecological information: Not available. 13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Follow all local, state, federal and provincial regulations for disposal. Hazardous waste number: Not a RCRA hazardous waste. 14. TRANSPORT INFORMATION The transport information provided in this section only applies to the material/formulation itself, and is not specific to any package/configuration. U.S. Department of Transportation Ground (49 CFR) Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None International Air Transportation (ICAO/IATA) Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None Water Transportation (IMO/IMDG) Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None IDH number: 495549 Product name: LOCTITE LB 8423 DIELECTRIC TUNE-UP GREASE known as LOCTITE? DIELECTRIC TUNE-UP G Page 5 of 5 15. REGULATORY INFORMATION United States Regulatory Information TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. TSCA 12 (b) Export Notification: None above reporting de minimis CERCLA/SARA Section 302 EHS: None above reporting de minimis CERCLA/SARA Section 311/312: Immediate Health CERCLA/SARA Section 313: None above reporting de minimis California Proposition 65: This product contains a chemical known in the State of California to cause cancer. Canada Regulatory Information CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Canadian Domestic Substances List. 16. OTHER INFORMATION This safety data sheet contains changes from the previous version in sections: New Safety Data Sheet format. Prepared by: Catherine Bimler, Regulatory Affairs Specialist Issue date: 02/28/2014 DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation and its affiliates (?Henkel?) does not assume responsibility for any results obtained by persons over whose methods Henkel has no control. It is the user?s responsibility to determine the suitability of Henkel?s products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any Henkel?s products. In light of the foregoing, Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel?s products. Henkel further disclaims any liability for consequential or incidental damages of any kind, including lost profits.