Data Sheet The Berkebile Oil Company DS ? MSDS Number: B2200 ? Berkebile Oil - Undercoating B-2200 Revision Date: 6/9/15 Page 1 of 6 Name The Berkebile Oil Company Address 1216 Red Brant Road Somerset, PA 15501, PO BOX 715 Phone 814-443-1656 Email This email address is being protected from spambots. You need JavaScript enabled to view it. Fax 814-443-2873 Chemtrec Emergency Tel # 800-424-9300 ? Product Name: Revision Date Version: MSDS Number: Common Name: Product Use: Berkebile Oil - Undercoating B-2200 6/4/2015 New 1251131-AP11131 Rubberized Undercoating Undercoating Route of Entry: Eyes - Yes Skin - Yes Inhalation - Yes Ingestion - Unlikely Target Organs: Skin, Eyes, Respiratory System, Nervous System. Inhalation: Breathing of vapor or mist is possible. Breathing small amounts of this material during normal handling is not likely to cause harmful effects. May be harmful if inhaled in excess. Vapors may cause drowsiness and dizziness. Skin Contact: Can cause skin irritation. Prolonged or repeated contact may dry the skin. Symptoms may include redness, burning, drying and cracking of skin. Eye Contact: May cause irritation. Symptoms include stinging, tearing, redness and swelling of eyes. Ingestion: Not a normal route of exposure. Swallowing small amounts of this material during normal handling is not likely to cause harmful effects. Swallowing large amounts may be harmful. This material can get into the lungs during swallowing or vomiting. This results in lung inflammation and other lung injury. NFPA: HMIS III: Health = 2, Fire = 3, Reactivity = 0 H2/F3/PH0 1 DUCT AND COMPANY DENT CAT N 2 HAZARDS DENT CAT N 3 2 0 2 3 0 B Safety asses, ves Data Sheet The Berkebile Oil Company DS ? MSDS Number: B2200 Berkebile Oil - Undercoating B-2200 Revision Date: 6/4/2015 Page 2 of 6 GHS Signal Word: DANGER GHS Hazard Pictograms: GHS Classifications: Physical, Flammable Aerosols, 1 Health, Acute toxicity, 4 Oral Health, Aspiration hazard, 2 Health, Skin corrosion/irritation, 2 Health, Serious Eye Damage/Eye Irritation, 2 B Health, Specific target organ toxicity - Single exposure, 3 Health, Reproductive toxicity, 2 Health, Specific target organ toxicity - Repeated exposure, 2 GHS Phrases: H222 - Extremely flammable aerosol H229 - Pressurized container: may burst if heated H302 - Harmful if swallowed H305 - May be harmful if swallowed and enters airways H315 - Causes skin irritation H320 - Causes eye irritation H335 - May cause respiratory irritation H336 - May cause drowsiness or dizziness H361 - Suspected of damaging fertility or the unborn child H373 - May cause damage to organs through prolonged or repeated exposure GHS Precautionary Statements: P102 - Keep out of reach of children. P103 - Read label before use. P210 - Keep away from heat/sparks/open flames/hot surfaces. No smoking P243 - Take precautionary measures against static discharge. P261 - Avoid breathing dust/fume/gas/mist/vapors/spray. P263 - Avoid contact during pregnancy/while nursing. P270 - Do not eat, drink or smoke when using this product. P281 - Use personal protective equipment as required. P301+330+331 - IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. P301+312 - IF SWALLOWED: Call a POISON CENTER or doctor/physician if you feel unwell. P302+352 - IF ON SKIN: Wash with soap and water. P304+341 - IF INHALED: If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing. P305+351+338 - IF IN EYES: Rinse continuously with water for several minutes. Remove contact lenses if present and easy to do. Continue rinsing. P312 - Call a POISON CENTER or doctor/physician if you feel unwell. P410+412 - Protect from sunlight. Do not expose to temperatures exceeding 50 ?C/122 ?F CONDITIONS AGGRAVATED BY EXPOSURE: Pre-existing skin and respiratory conditions. LISTED CARCINOGENS: OSHA - Not listed IARC - Yes (2B) NTP - Not listed Data Sheet The Berkebile Oil Company DS ? MSDS Number: B2200 Berkebile Oil - Undercoating B-2200 Revision Date: 6/4/2015 Page 3 of 6 Ingredients: Cas # | Percentage | Chemical Name ------------------------------------------------------------------------------------------------------- 64742-93-4 | 10-20% | Asphalt, oxidized 68476-86-8 | 10-20% | Petroleum gases, liquefied 8052-41-3 | 10-20% | Stoddard solvent 108-88-3 | 5-15% | Toluene 67-64-1 | 1-5% | Acetone 14807-96-6 | <0.1% | Talc (Mg3H2(SiO3)4) 14808-60-7 | <0.1% | Quartz (SiO2) Inhalation: Skin Contact: Eye Contact: Ingestion: Move to fresh air and keep at rest. Call a physician if symptoms develop and persist. Wash with soap and water. If skin irritation persists, call a physician immediately. Remove contaminated clothing and wash before reuse. Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists. Rinse mouth. Do not induce vomiting without advice from poison control center. If vomiting occurs, keep head low to avoid getting into the lungs. Call a poison control center if large amounts are ingested. Never give anything by mouth to an unconscious person. Flammability: Extremely Flammable per Flame Projection Test Flash Point: -4?F (-20?C) (concentrate) / -156?F (-104.4?C) (propellant) Flash Point Method: Estimated Autoignition Temp: Not established LEL: Not established UEL: Not established Means of Extinction: Suitable Extinguishing Media: Powder, foam, carbon dioxide. Unsuitable Extinguishing Media: Not available. Products of Combustion: May include, and are not limited to: oxides of carbon. Explosion Data: Sensitivity to Mechanical Impact: Not available. Sensitivity to Static Discharge: Not available. Protection of Firefighters: Containers may explode when heated. Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). Personal Precautions: Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. Eliminate sources of ignition. Ruptured cylinders may rocket. Environmental Precautions: Many gases are heavier than air and will spread along ground 3 COMP N/ NF RMAT N N NGREDIENTS 4 RS AID MEASURE 5 RE HT NG MEASURE 6 ACCIDENTAL RE AS ASURE Data Sheet The Berkebile Oil Company DS ? MSDS Number: B2200 Berkebile Oil - Undercoating B-2200 Revision Date: 6/4/2015 and collect in low or confined areas (sewers, basements, tanks). This material is a water pollutant. Keep out of drains, sewers, ditches, and waterways. Minimize use of water to prevent environmental contamination. Methods for Containment: Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter waterways. Use appropriate Personal Protective Equipment (PPE). Methods for Clean-Up: Vacuum or sweep material and place in a disposal container. Allow gas to dissipate harmlessly into the atmosphere. Page 4 of 6 Handling Precautions: Storage Requirements: HARMFUL IF INHALED OR SWALLOWED. VAPOR HARMFUL. VAPORS MAY CAUSE FLASH FIRE. EYE, SKIN AND RESPIRATORY IRRITANT. Contents under pressure. Keep out of reach of children. Read label cautions carefully. Follow label directions to avoid injury. Use with adequate ventilation. Do not use in confined areas. Keep away from heat, sparks or open flames. Wash hands thoroughly after each use. Do not smoke while using. Avoid contact with skin and eyes. Avoid breathing vapor or mist. Do not puncture container. Keep out of reach of children. Do not store near heat, sparks, or open flames. Do not expose to temperatures above 120?F as container may vent, rupture or burst. Do not puncture or incinerate container. Store in accordance with NFPA 30B for LEVEL 2 AEROSOL. Engineering Controls: Personal Protective Equip: Use ventilation adequate to keep exposures below recommended exposure limits. HMIS PP, B | Safety Glasses, Gloves Eye Protection: Wear eye/face protection. Hand Protection: Wear suitable gloves. Skin and Body Protection: Wear suitable protective clothing. Respiratory Protection: In case of insufficient ventilation, wear suitable respiratory equipment. EXPOSURE LIMITS INGREDIENTS OSHA-PEL ACGIH-TLV OTHER Asphalt, oxidized 5mg/m3 (oil mist) 0.5mg/m3 (fume) 5mg/m3 (oil mmist) REL Petroleum gases, liquefied Not established 1000 ppm Stoddard solvent Not established 100 ppm 350 ppm (1800mg/m3) REL Toluene 200 ppm 500 ppm (skin) 150 ppm (skin) STEL Acetone 750ppm (1800mg/m3) 500 ppm (750ppm STEL) 250ppm (590mg/m3) NIOSH 1000ppm (2400mg/m3) STEL Talc (Mg3H2(SiO3)4) 2mg/m3 (dust) 2mg/m3 (dust) Quartz (SiO2) 0.1mg/m3 (dust) 0.025 mg/m3 (resp fraction) 7 HANDL NG AND S RAGE 8 URE CONTRO RS NAL PRO N Data Sheet The Berkebile Oil Company DS ? MSDS Number: B2200 Berkebile Oil - Undercoating B-2200 Revision Date: 6/4/2015 Page 5 of 6 Appearance: black opaque liquid Physical State: Mixture packaged in pressurized aerosol spray can. Odor: solvent Solubility: Insoluble in water Spec Grav./Density: 0.99-1.03 (concentrate) Viscosity: 1800 - 2400 cP Heat Value: 25.9 kJ/g Flammability: Flammable Flash Point: -4?F (-20?C) (concentrate) / -156?F (-104.4?C) (propellant) pH: Not applicable VOC: 41.07 % Evap. Rate: >1.00 (BuAc=1) UFL/LFL: Not established Stability: Conditions to Avoid: Materials to Avoid: Hazardous Decomposition: Hazardous Polymerization: Product is stable under normal conditions. Heat, sparks, open flames and temperatures above 120?F Strong Oxidizing Agents. CO, CO2, and hydrocarbons. Will not occur. Not established Not established Do not allow into drains or water sources. Waste and empty containers should be disposed of in accordance with regulations made under the Control of Pollution Act and the Enviromental Protection Act. Using information provided in this data sheet advice should be obtained from the Waste Regulation Authority, weather special waste regulations apply. DOT Class: Flammable Gas (2.1) #2.1 UN #: UN 1950, Class: 2, Proper Shipping Name: Aerosols, flammable COMPONENT / (CAS/PERC) / CODES ---------------------------------------------------------------- 9 HY CAL AND CHE CAL PROPERT 10 ABI AND REACT 11 CO CAL NF RMAT N 12 CAL NF RMAT N 13 DISP NS DERAT NS 14 RANS RT NF RMAT N 15 RE ULAT RY NF RMAT N Data Sheet The Berkebile Oil Company DS ? MSDS Number: B2200 Berkebile Oil - Undercoating B-2200 Revision Date: 6/4/2015 Page 6 of 6 *Asphalt, oxidized (64742934 10-20%) TSCA *Petroleum gases, liquefied, sweetened (68476868 10-20%) TSCA *Stoddard solvent (8052413 10-20%) MASS, OSHAWAC, PA, TSCA, TXAIR *Toluene (108883 5-15%) CERCLA, CSWHS, EPCRAWPC, HAP, MASS, NJHS, OSHAWAC, PA, PRIPOL, PROP65, SARA313, TOXICPOL, TOXICRCRA, TSCA, TXAIR, TXHWL *Acetone (67641 1-5%) CERCLA, HAP, MASS, NJHS, OSHAWAC, PA, SARA313, TOXICRCRA, TSCA, TXAIR, TXHWL REGULATORY KEY DESCRIPTIONS TSCA = Toxic Substances Control Act MASS = MA Massachusetts Hazardous Substances List OSHAwAC = OSHA workplace Air Contaminants PA = PA Right To Know List of Hazardous Substances TXAIR = TX Air Contaminants with Health Effects Screening Level CERCLA = Superfund clean up substance CSwHS = Clean water Act Hazardous substances EPCRAwPC = EPCRA water Priority Chemicals HAP = Hazardous Air Pollutants NJHS = NJ Right to Know Hazardous Substances PRIPOL = Clean water Act Priority Pollutants PROP65 = CA Prop 65 SARA313 = SARA 313 Title III Toxic Chemicals TOXICPOL = Clean water Act Toxic Pollutants TOXICRCRA = RCRA Toxic Hazardous wastes (U List) TXHwL = TX Hazardous waste List California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): WARNING: ?This ?product ?contains ?a ?chemical(s) ?known ?to ?the ?State ?of ?California ?to ?cause ?cancer, ?birth ?defects ?or ?other ? reproductive ?harm. ? ? ? ? ? ? ? The information provided herein was believed to be accurate at the time of preparation and prepared from a compilation of sources believed to be reliable, but it is the responsibility of the user to investigate and understand other pertinent sources of information, to comply with all laws and procedures applicable to the safe handling and use of this product, and to determine the suitability of the product for its intended use. Author: Zach Sherbine Publication Date: 6/4/15 Revision No.: NEW 16 HER NF RMAT N