SAFETY DATA SHEET Revision Date 23-Mar-2021 Version 4 1. IDENTIFICATION Product identifier Product Name Gumout Jet Spray Carb and Choke Cleaner Other means of identification Product Code 600951 Document SKU: 800002230, 800002231, 800002241 Recommended use of the chemical and restrictions on use Recommended Use Carburetor Cleaner Consumer Use Uses advised against All other applications Details of the supplier of the safety data sheet Company Phone Number 1-855-888-1988 24-hour emergency phone number (CHEMTREC) 1-800-424-9300 or 1-703-527-3887 (U.S.) (RMPDC) 1-877-504-9352 (U.S.) E-mail address: This email address is being protected from spambots. You need JavaScript enabled to view it. 2. HAZARDS IDENTIFICATION Classification OSHA Regulatory Status This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) Serious eye damage/eye irritation Category 2 Reproductive toxicity Category 2 Specific target organ toxicity (single exposure) Category 3 Specific target organ toxicity (repeated exposure) Category 2 Label elements Emergency Overview Supplier Address ITW Global Brands 16200 Park Row, Suite 120 Houston, TX 77084 Manufacturer Address Distributor May Also Be Distributed by: ITW Permatex Canada 101-2360 Bristol Circle Oakville, ON Canada L6H 6M5 Telephone: (800) 924-6994 Flammable aerosols Category 1 Gases under pressure Compressed gas Signal word Danger _____________________________________________________________________________________________ Page 1 / 9 Causes serious eye irritation Suspected of damaging fertility or the unborn child May cause drowsiness or dizziness May cause damage to organs through prolonged or repeated exposure Extremely flammable aerosol _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 Precautionary Statements - Prevention Obtain special instructions before use Do not handle until all safety precautions have been read and understood Use personal protective equipment as required Wash face, hands and any exposed skin thoroughly after handling Wear eye/face protection Do not breathe dust/fume/gas/mist/vapors/spray Use only outdoors or in a well-ventilated area Do not puncture or incinerate container Contents under pressure and can explode when exposed to heat or open flame Keep away from heat/sparks/open flames/hot surfaces. - No smoking Precautionary Statements - Response IF exposed or concerned: Get medical advice/attention IF SWALLOWED: Rinse mouth. DO NOT induce vomiting IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing Precautionary Statements - Storage Store locked up Store in a well-ventilated place. Keep container tightly closed Do not expose to temperatures exceeding 120 ?F (49 ?C) Keep away from heat, sparks, flames and other ignition sources Keep out of reach of children Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable Other Information Causes mild skin irritation. May be harmful if inhaled or swallowed. Harmful to aquatic life with long lasting effects. 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No Weight-% ACETONE 67-64-1 60 - 100 TOLUENE 108-88-3 5 - 10 CARBON DIOXIDE 124-38-9 5 - 10 4. FIRST AID MEASURES Contains gas under pressure; may explode if heated Appearance Colorless Physical state Liquid Flammable Aerosol Odor Alcohol _____________________________________________________________________________________________ Page 2 / 9 _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 Description of first aid measures General advice Get medical advice/attention if you feel unwell. Eye contact IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Skin contact IF ON SKIN:. Wash skin with soap and water. If skin irritation persists, call a physician. Take off contaminated clothing and wash before reuse. Inhalation IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. If symptoms persist, call a physician. Ingestion IF SWALLOWED:. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician. Self-protection of the first aider Ensure that medical personnel are aware of the material(s) involved and take precautions to protect themselves. Most important symptoms and effects, both acute and delayed Symptoms See section 2 for more information. Indication of any immediate medical attention and special treatment needed Note to physicians Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Dry chemical, CO2, sand, earth, water spray or regular foam Unsuitable extinguishing media None Specific hazards arising from the chemical Extremely flammable. Contents under pressure and can explode when exposed to heat or flames. Vapors may cause flash fire. Explosion data Sensitivity to Mechanical Impact None. Sensitivity to Static Discharge May be ignited by heat, sparks or flames. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Ensure adequate ventilation, especially in confined areas. Avoid contact with skin, eyes and inhalation of vapors. Use personal protective equipment as required. Remove all sources of ignition. Environmental precautions Environmental precautions See Section 12 for additional Ecological Information. Methods and material for containment and cleaning up _____________________________________________________________________________________________ Page 3 / 9 _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 Methods for containment Prevent further leakage or spillage if safe to do so. Methods for cleaning up Ensure adequate ventilation. Soak up with inert absorbent material. Sweep up and shovel into suitable containers for disposal. Use personal protective equipment as required. Prevention of secondary hazards Clean contaminated objects and areas thoroughly observing environmental regulations. 7. HANDLING AND STORAGE Precautions for safe handling Advice on safe handling Handle in accordance with good industrial hygiene and safety practice. Avoid breathing vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling. Wash contaminated clothing before reuse. Use personal protective equipment as required. Conditions for safe storage, including any incompatibilities Storage Conditions Keep containers tightly closed in a cool, well-ventilated place. Keep away from sunlight, ignition sources and other sources of heat. Do not expose to temperatures exceeding 50 ?C/122 ?F. Keep out of the reach of children. Incompatible materials Strong oxidizing agents 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Exposure Guidelines . Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH ACETONE 67-64-1 STEL: 500 ppm TWA: 250 ppm TWA: 1000 ppm TWA: 2400 mg/m3 (vacated) TWA: 750 ppm (vacated) TWA: 1800 mg/m3 (vacated) STEL: 2400 mg/m3 The acetone STEL does not apply to the cellulose acetate fiber industry. It is in effect for all other sectors. (vacated) STEL: 1000 ppm IDLH: 2500 ppm TWA: 250 ppm TWA: 590 mg/m3 TOLUENE 108-88-3 TWA: 20 ppm TWA: 200 ppm (vacated) TWA: 100 ppm (vacated) TWA: 375 mg/m3 (vacated) STEL: 150 ppm (vacated) STEL: 560 mg/m3 Ceiling: 300 ppm IDLH: 500 ppm TWA: 100 ppm TWA: 375 mg/m3 STEL: 150 ppm STEL: 560 mg/m3 CARBON DIOXIDE 124-38-9 STEL: 30000 ppm TWA: 5000 ppm TWA: 5000 ppm TWA: 9000 mg/m3 (vacated) TWA: 10000 ppm (vacated) TWA: 18000 mg/m3 (vacated) STEL: 30000 ppm (vacated) STEL: 54000 mg/m3 IDLH: 40000 ppm TWA: 5000 ppm TWA: 9000 mg/m3 STEL: 30000 ppm STEL: 54000 mg/m3 NIOSH IDLH Immediately Dangerous to Life or Health Other Information Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Controls Showers Eyewash stations Ventilation systems _____________________________________________________________________________________________ Page 4 / 9 Individual protection measures, such as personal protective equipment _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 Eye/face protection Wear safety glasses with side shields (or goggles). Skin and body protection Wear protective natural rubber, nitrile rubber, Neoprene? or PVC gloves. Respiratory protection Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as appropriate. General Hygiene Considerations Handle in accordance with good industrial hygiene and safety practice. Regular cleaning of equipment, work area and clothing is recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on basic physical and chemical properties Physical state Liquid Flammable Aerosol Appearance Colorless Odor Alcohol Odor threshold No information available Explosive properties No information available Oxidizing properties No information available Other Information Softening point No information available Molecular weight No information available Density 0.797 g/cm3 Bulk density No information available SADT (self-accelerating decomposition temperature) No information available 10. STABILITY AND REACTIVITY Reactivity Chemical stability Stable under normal conditions Possibility of Hazardous Reactions None under normal processing. Conditions to avoid Property Values Remarks ? Method pH No information available Melting point / freezing point No information available Boiling point / boiling range 56 ?C / 133 ?F Flash point -20 ?C / -4 ?F Tag Closed Cup Evaporation rate No information available Flammability (solid, gas) No information available Flammability Limit in Air Upper flammability limit: 2.6 Lower flammability limit: 12.8 Vapor pressure 185 Vapor density No information available Relative density 0.798 Water solubility Miscible in water Solubility(ies) No information available Partition coefficient No information available Autoignition temperature 465 ?C / 869 ?F Decomposition temperature No information available Kinematic viscosity No information available Dynamic viscosity No information available Stable under normal use _____________________________________________________________________________________________ Page 5 / 9 _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 Keep away from all heat sources, open flames and other sources of ignition. Incompatible materials Strong oxidizing agents Hazardous Decomposition Products Carbon oxides 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure Inhalation May cause irritation of respiratory tract. May cause central nervous system depression with nausea, headache, dizziness, vomiting, and incoordination. Intentional misuse by deliberately concentrating and inhaling contents may be harmful or fatal. Harmful by inhalation. Eye contact Contact with eyes may cause irritation. May cause redness and tearing of the eyes. Skin contact May cause skin irritation and/or dermatitis. Ingestion Ingestion may cause irritation to mucous membranes. Potential for aspiration if swallowed. Aspiration may cause pulmonary edema and pneumonitis. May be fatal if swallowed. Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 ACETONE 67-64-1 = 5800 mg/kg ( Rat ) > 15700 mg/kg ( Rabbit ) = 50100 mg/m3 ( Rat ) 8 h TOLUENE 108-88-3 = 2600 mg/kg ( Rat ) = 12000 mg/kg ( Rabbit ) = 12.5 mg/L ( Rat ) 4 h Information on toxicological effects Symptoms No information available. Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization No information available. Germ cell mutagenicity No information available. Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Chemical Name ACGIH IARC NTP OSHA TOLUENE 108-88-3 - Group 3 - - IARC (International Agency for Research on Cancer) Not classifiable as a human carcinogen Chronic toxicity May cause adverse liver effects. Target Organ Effects Central nervous system, Central Vascular System (CVS), Eyes, kidney, Liver, Respiratory system, Skin. The following values are calculated based on chapter 3.1 of the GHS document . ATEmix (oral) 5526 mg/kg ATEmix (dermal) 122449 mg/kg ATEmix (inhalation-dust/mist) 62 mg/l 12. ECOLOGICAL INFORMATION Ecotoxicity Persistence and degradability No information available. _____________________________________________________________________________________________ Page 6 / 9 Bioaccumulation _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 No information available. Mobility Disperses in water. Chemical Name Partition coefficient ACETONE 67-64-1 -0.24 TOLUENE 108-88-3 2.7 Other adverse effects No information available 13. DISPOSAL CONSIDERATIONS Waste treatment methods Disposal of wastes Recover or recycle if possible. Disposal should be in accordance with applicable regional, national and local laws and regulations. Contaminated packaging Do not reuse container. US EPA Waste Number D001 Chemical Name RCRA - Halogenated Organic Compounds RCRA - P Series Wastes RCRA - F Series Wastes RCRA - K Series Wastes TOLUENE 108-88-3 - - Toxic waste waste number F025 Waste description: Condensed light ends, spent filters and filter aids, and spent desiccant wastes from the production of certain chlorinated aliphatic hydrocarbons, by free radical catalyzed processes. These chlorinated aliphatic hydrocarbons are those having carbon chain lengths ranging from one to and including five, with varying amounts and positions of chlorine substitution. - This product contains one or more substances that are listed with the State of California as a hazardous waste. Chemical Name California Hazardous Waste Status ACETONE 67-64-1 Ignitable TOLUENE 108-88-3 Toxic Ignitable 14. TRANSPORT INFORMATION DOT UN/ID No UN 1950 Proper shipping name Aerosols, Flammable Liquid NOS (Petroleum Distillates), Limited Quantity (LQ) Hazard Class 2.1 IATA UN/ID No UN 1950 _____________________________________________________________________________________________ Page 7 / 9 _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 Proper shipping name Aerosols, Flammable Liquid NOS (Petroleum Distillates), Limited Quantity (LQ) Hazard Class 2.1 IMDG UN/ID No UN 1950 Proper shipping name Aerosols, Flammable Liquid NOS (Petroleum Distillates), Limited Quantity (LQ) Hazard Class 2.1 15. REGULATORY INFORMATION International Inventories TSCA Complies DSL/NDSL Complies EINECS/ELINCS Complies ENCS Does not comply IECSC Complies KECL Does not comply PICCS Complies AICS Does not comply Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 Chemical Name SARA 313 - Threshold Values % TOLUENE - 108-88-3 1.0 SARA 311/312 Hazard Categories Acute health hazard No Chronic Health Hazard No Fire hazard No Sudden release of pressure hazard No Reactive Hazard No CWA (Clean Water Act) This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42) Chemical Name CWA - Reportable Quantities CWA - Toxic Pollutants CWA - Priority Pollutants CWA - Hazardous Substances TOLUENE 108-88-3 1000 lb X X X CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ) ACETONE 67-64-1 5000 lb - RQ 5000 lb final RQ RQ 2270 kg final RQ TOLUENE 108-88-3 1000 lb 1 lb - RQ 1000 lb final RQ RQ 454 kg final RQ RQ 1 lb final RQ _____________________________________________________________________________________________ Page 8 / 9 _____________________________________________________________________________________________ 600951 - Gumout Jet Spray Carb and Choke Cleaner Revision Date 23-Mar-2021 RQ 0.454 kg final RQ US State Regulations California Proposition 65 This product contains the following Proposition 65 chemicals Chemical Name California Proposition 65 TOLUENE 108-88-3 Developmental U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania ACETONE 67-64-1 X X X TOLUENE 108-88-3 X X X CARBON DIOXIDE 124-38-9 X X X U.S. EPA Label Information EPA Pesticide Registration Number Not applicable WHMIS Hazard Class Non-controlled 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION OF THE LAST REVISION NFPA (National Fire Protection Association) HMIS (Hazardous Material Information System) Revision Date 23-Mar-2021 Revision Note 4 Disclaimer Illinois Tool Works Inc. believes the information contained in this data sheet is accurate as of the date compiled. However, Illinois Tool Works Inc. makes no warranty, express or implied, as to the accuracy, reliability or completeness of the information. User is responsible for evaluating whether such information or this product is fit for a particular purpose and suitable for a particular use or application. The information in this data sheet may not be valid if this product is used in combination with other products or in processes for which it was not designed. Illinois Tool Works Inc. disclaims any liability for consequential or incidental damages of any kind, including lost profits, arising from the sale or use of this product. Ensure you have the most current version of this data sheet by contacting us or reviewing our web site. End of Safety Data Sheet NFPA Health hazards 2 Flammability 3 Instability 0 - HMIS Health hazards 2 Flammability 3 Physical hazards 1 Personal protection B _____________________________________________________________________________________________ Page 9 / 9