SAFETY DATA SHEET 1. Identification Product identifier Power Lube? Multi-Purpose Lubricant Other means of identification Product code 05005, 05006, 85005 Recommended use Multi-purpose lubricant Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Manufactured or sold by: Company name CRC Industries, Inc. Address 885 Louis Dr. Warminster, PA 18974 US Telephone General Information 215-674-4300 Technical Assistance 800-521-3168 Customer Service 800-272-4620 24-Hour Emergency 800-424-9300 (US) (CHEMTREC) 703-527-3887 (International) Website www.crcindustries.com 2. Hazard(s) identification Category 1Flammable aerosolsPhysical hazards Compressed gasGases under pressure Category 2Skin corrosion/irritationHealth hazards Category 3 narcotic effectsSpecific target organ toxicity, single exposure Category 2Specific target organ toxicity, repeated exposure Category 1Aspiration hazard Category 2Hazardous to the aquatic environment, acute hazard Environmental hazards Not classified.OSHA defined hazards Label elements Signal word Danger Hazard statement Extremely flammable aerosol. Contains gas under pressure; may explode if heated. May be fatal if swallowed and enters airways. Causes skin irritation. May cause drowsiness or dizziness. May cause damage to organs through prolonged or repeated exposure. Toxic to aquatic life. Precautionary statement Prevention Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not spray on an open flame or other ignition source. Do not apply while equipment is energized. Pressurized container: Do not pierce or burn, even after use. Use only with adequate ventilation; maintain ventilation during use and until all vapors are gone. Open doors and windows or use other means to ensure a fresh air supply during use and while product is drying. If you experience any symptoms listed on this label, increase ventilation or leave the area. Extinguish all flames, pilot lights and heaters. Vapors will accumulate readily and may ignite. Do not breathe gas, mist or vapor. Wear protective gloves. Wash hands thoroughly after handling. Avoid release to the environment. Response If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. If on skin: Wash with plenty of water. If skin irritation occurs: Get medical attention. Take off contaminated clothing and wash before reuse. If inhaled: Remove person to fresh air and keep comfortable for breathing. Call a poison center/doctor if you feel unwell. Storage Store in a well-ventilated place. Store locked up. Protect from sunlight. Do not expose to temperatures exceeding 50?C/122?F. Exposure to high temperature may cause can to burst. Disposal Dispose of contents/container in accordance with local/regional/national regulations. 1 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US Hazard(s) not otherwise classified (HNOC) None known. Supplemental information 35% of the mixture consists of component(s) of unknown acute hazards to the aquatic environment. 3. Composition/information on ingredients Mixtures CAS number %Chemical name Common name and synonyms 64742-47-8Distillates (petroleum), hydrotreated light 60 - 70 64741-88-4Distillates (petroleum), solvent-refined heavy paraffinic 10 - 20 123-95-5n-Butyl stearate 3 - 5 124-38-9Carbon dioxide 1 - 3 119-36-8Methyl salicylate 1 - 3 8009-03-8Petrolatum 1 - 3 68910-94-1Sorbitan monooleate 1 - 3 Specific chemical identity and/or percentage of composition has been withheld as a trade secret. 4. First-aid measures Inhalation Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or doctor/physician if you feel unwell. Skin contact Rinse skin with water/shower. If skin irritation occurs: Get medical advice/attention. Take off contaminated clothing and wash before reuse. Eye contact Rinse with water. Get medical attention if irritation develops and persists. Ingestion Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If vomiting occurs, keep head low so that stomach content doesn't get into the lungs. Aspiration may cause pulmonary edema and pneumonitis. Most important symptoms/effects, acute and delayed Skin irritation. Vapors have a narcotic effect and may cause headache, fatigue, dizziness and nausea. May cause drowsiness or dizziness. May cause redness and pain. Prolonged exposure may cause chronic effects. Indication of immediate medical attention and special treatment needed Provide general supportive measures and treat symptomatically. Keep victim under observation. Symptoms may be delayed. General information Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. 5. Fire-fighting measures Suitable extinguishing media Alcohol resistant foam. Water. Water spray. Dry powder. Dry chemicals. Carbon dioxide (CO2). Unsuitable extinguishing media Do not use water jet as an extinguisher, as this will spread the fire. Specific hazards arising from the chemical Contents under pressure. Pressurized container may explode when exposed to heat or flame. Special protective equipment and precautions for firefighters Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA. Fire-fighting equipment/instructions In case of fire: Stop leak if safe to do so. Do not move cargo or vehicle if cargo has been exposed to heat. If tank, rail car or tank truck is involved in a fire, ISOLATE for 800 meters (1/2 mile) in all directions; also consider initial evacuation for 800 meters (1/2 mile) in all directions. ALWAYS stay away from tanks engulfed in flame. Move containers from fire area if you can do so without risk. Cool containers exposed to heat with water spray and remove container, if no risk is involved. Containers should be cooled with water to prevent vapor pressure build up. For massive fire in cargo area, use unmanned hose holder or monitor nozzles, if possible. If not, withdraw and let fire burn out. General fire hazards Extremely flammable aerosol. 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Wear appropriate protective equipment and clothing during clean-up. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Do not breathe gas, mist or vapor. Ventilate closed spaces before entering them. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS. 2 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US Methods and materials for containment and cleaning up Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. Environmental precautions Avoid release to the environment. Contact local authorities in case of spillage to drain/aquatic environment. Prevent further leakage or spillage if safe to do so. Do not contaminate water. Avoid discharge into drains, water courses or onto the ground. 7. Handling and storage Precautions for safe handling Pressurized container: Do not pierce or burn, even after use. Do not use if spray button is missing or defective. Do not spray on a naked flame or any other incandescent material. Do not smoke while using or until sprayed surface is thoroughly dry. Do not cut, weld, solder, drill, grind, or expose containers to heat, flame, sparks, or other sources of ignition. Use caution around energized equipment. The metal container will conduct electricity if it contacts a live source. This may result in injury to the user from electrical shock and/or flash fire. Do not re-use empty containers. Do not breathe mist or vapor. Do not breathe gas. Avoid contact with skin. Avoid contact with eyes. Avoid prolonged exposure. Avoid contact with clothing. Use only in well-ventilated areas. Wear appropriate personal protective equipment. Wash hands thoroughly after handling. Observe good industrial hygiene practices. Avoid release to the environment. Do not empty into drains. For product usage instructions, please see the product label. Conditions for safe storage, including any incompatibilities Level 3 Aerosol. Pressurized container. Protect from sunlight and do not expose to temperatures exceeding 50?C/122 ?F. Do not puncture, incinerate or crush. Do not handle or store near an open flame, heat or other sources of ignition. This material can accumulate static charge which may cause spark and become an ignition source. Store in a well-ventilated place. Store away from incompatible materials (see Section 10 of the SDS). Keep out of the reach of children. 8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) ValueComponents FormType PEL 9000 mg/m3Carbon dioxide (CAS 124-38-9) 5000 ppm PEL 5 mg/m3 Mist.Distillates (petroleum), solvent-refined heavy paraffinic (CAS 64741-88-4) 2000 mg/m3 500 ppm PEL 5 mg/m3 Mist.Petrolatum (CAS 8009-03-8) US. ACGIH Threshold Limit Values ValueComponents FormType STEL 30000 ppmCarbon dioxide (CAS 124-38-9) TWA 5000 ppm TWA 5 mg/m3 Inhalable fraction.Distillates (petroleum), solvent-refined heavy paraffinic (CAS 64741-88-4) TWA 10 mg/m3n-Butyl stearate (CAS 123-95-5) TWA 5 mg/m3 Inhalable fraction.Petrolatum (CAS 8009-03-8) US. NIOSH: Pocket Guide to Chemical Hazards ValueComponents FormType STEL 54000 mg/m3Carbon dioxide (CAS 124-38-9) 30000 ppm TWA 9000 mg/m3 5000 ppm TWA 100 mg/m3Distillates (petroleum), hydrotreated light (CAS 64742-47-8) STEL 10 mg/m3 Mist.Distillates (petroleum), solvent-refined heavy paraffinic (CAS 64741-88-4) 3 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US US. NIOSH: Pocket Guide to Chemical Hazards ValueComponents FormType TWA 5 mg/m3 Mist. STEL 10 mg/m3 Mist.Petrolatum (CAS 8009-03-8) TWA 5 mg/m3 Mist. Biological limit values No biological exposure limits noted for the ingredient(s). Appropriate engineering controls Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level. Eye wash facilities and emergency shower must be available when handling this product. Individual protection measures, such as personal protective equipment Eye/face protection Wear safety glasses with side shields (or goggles). Skin protection Hand protection Wear protective gloves such as neoprene or nitrile. Other Wear appropriate chemical resistant clothing. Respiratory protection Wear positive pressure self-contained breathing apparatus (SCBA). Air monitoring is needed to determine actual employee exposure levels. Thermal hazards Wear appropriate thermal protective clothing, when necessary. General hygiene considerations When using, do not eat, drink or smoke. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. 9. Physical and chemical properties Appearance Physical state Liquid. Form Aerosol. Color Amber. Odor Mint Odor threshold Not available. pH Not available. Melting point/freezing point -72.4 ?F (-58 ?C) estimated Initial boiling point and boiling range 212 ?F (100 ?C) estimated Flash point 196 ?F (91.1 ?C) Tag Closed Cup Evaporation rate Not available. Flammability (solid, gas) Not available. Upper/lower flammability or explosive limits Flammability limit - lower (%) 0.6 % estimated Flammability limit - upper (%) 5.5 % estimated Vapor pressure 2074.6 hPa estimated Vapor density Not available. Relative density 0.85 estimated Solubility (water) Not available. Partition coefficient (n-octanol/water) Not available. Auto-ignition temperature 456.8 ?F (236 ?C) estimated Decomposition temperature Not available. Viscosity (kinematic) Not available. Percent volatile 78.8 % estimated 10. Stability and reactivity Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport. Chemical stability Material is stable under normal conditions. 4 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US Possibility of hazardous reactions No dangerous reaction known under conditions of normal use. Conditions to avoid Avoid heat, sparks, open flames and other ignition sources. Avoid temperatures exceeding the flash point. Contact with incompatible materials. Incompatible materials Strong oxidizing agents. Hazardous decomposition products No hazardous decomposition products are known. 11. Toxicological information Information on likely routes of exposure Ingestion May be fatal if swallowed and enters airways. Inhalation Vapors have a narcotic effect and may cause headache, fatigue, dizziness and nausea. Prolonged inhalation may be harmful. May cause damage to organs by inhalation. Skin contact Causes skin irritation. Eye contact Direct contact with eyes may cause temporary irritation. Symptoms related to the physical, chemical and toxicological characteristics Skin irritation. May cause redness and pain. Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting. Information on toxicological effects Acute toxicity May be fatal if swallowed and enters airways. Narcotic effects. Test ResultsProduct Species Power Lube? Multi-Purpose Lubricant LD50 Rabbit Dermal Acute 2856.9861 mg/kg estimated LC50 Rat Inhalation 7.8462 mg/l estimated LD50 Rat Oral 6164.1128 mg/kg estimated LD50 Rat Oral Subchronic 783.0176 g/kg, 14 days estimated * Estimates for product may be based on additional component data not shown. Skin corrosion/irritation Causes skin irritation. Serious eye damage/eye irritation Direct contact with eyes may cause temporary irritation. Respiratory sensitization Not available. Skin sensitization This product is not expected to cause skin sensitization. Germ cell mutagenicity No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. Reproductive toxicity This product is not expected to cause reproductive or developmental effects. Specific target organ toxicity - single exposure Narcotic effects. Specific target organ toxicity - repeated exposure May cause damage to organs through prolonged or repeated exposure. Aspiration hazard May be fatal if swallowed and enters airways. Chronic effects Prolonged inhalation may be harmful. May cause damage to organs through prolonged or repeated exposure. 12. Ecological information Ecotoxicity Toxic to aquatic life. Product Test ResultsSpecies Power Lube? Multi-Purpose Lubricant Acute LC50Fish 4942.9658 ppm, 96 hours estimatedFish 5 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US Components Test ResultsSpecies * Estimates for product may be based on additional component data not shown. Distillates (petroleum), hydrotreated light (CAS 64742-47-8) Aquatic Acute LC50Fish 2.2 mg/l, 96 hoursBluegill (Lepomis macrochirus) Persistence and degradability No data is available on the degradability of this product. Bioaccumulative potential No data available. Partition coefficient n-octanol / water (log Kow) Methyl salicylate 2.55 Mobility in soil No data available. Other adverse effects No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. 13. Disposal considerations Disposal of waste from residues / unused products The dispensed liquid product is not a RCRA hazardous waste (See 40 CFR Part 261.20 - 261.33). Empty container can be recycled. Consult authorities before disposal. Contents under pressure. Do not puncture, incinerate or crush. Do not allow this material to drain into sewers/water supplies. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of contents/container in accordance with local/regional/national regulations. Hazardous waste code Not regulated. Contaminated packaging Empty containers should be taken to an approved waste handling site for recycling or disposal. Since emptied containers may retain product residue, follow label warnings even after container is emptied. Do not re-use empty containers. 14. Transport information DOT UN1950UN number Aerosols, flammable, limited quantityUN proper shipping name 2.1Class Transport hazard class(es) -Subsidiary risk 2.1Label(s) Not applicable.Packing group Read safety instructions, SDS and emergency procedures before handling.Special precautions for user N82Special provisions 306Packaging exceptions NonePackaging non bulk NonePackaging bulk IATA UN1950UN number Aerosols, flammable, limited quantityUN proper shipping name 2.1Class Transport hazard class(es) -Subsidiary risk Not applicable.Packing group No.Environmental hazards 10LERG Code Read safety instructions, SDS and emergency procedures before handling.Special precautions for user Allowed.Passenger and cargo aircraft Other information Allowed.Cargo aircraft only IMDG UN1950UN number AEROSOLS, LIMITED QUANTITYUN proper shipping name 2Class Transport hazard class(es) -Subsidiary risk Not applicable.Packing group No.Marine pollutant Environmental hazards F-D, S-UEmS 6 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US Read safety instructions, SDS and emergency procedures before handling.Special precautions for user 15. Regulatory information US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. SARA 304 Emergency release notification Not regulated. US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. US EPCRA (SARA Title III) Section 313 - Toxic Chemical: Listed substance Not listed. CERCLA Hazardous Substance List (40 CFR 302.4) Not listed. CERCLA Hazardous Substances: Reportable quantity Not listed. Spills or releases resulting in the loss of any ingredient at or above its RQ require immediate notification to the National Response Center (800-424-8802) and to your Local Emergency Planning Committee. Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Not regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130) Not regulated. Safe Drinking Water Act (SDWA) Not regulated. Food and Drug Administration (FDA) Not regulated. Superfund Amendments and Reauthorization Act of 1986 (SARA) Section 311/312 Hazard categories Immediate Hazard - Yes Delayed Hazard - Yes Fire Hazard - Yes Pressure Hazard - Yes Reactivity Hazard - No SARA 302 Extremely hazardous substance No US state regulations US. New Jersey RTK - Substances: Listed substance Carbon dioxide (CAS 124-38-9) US. Massachusetts RTK - Substance List Carbon dioxide (CAS 124-38-9) US. Pennsylvania RTK - Hazardous Substances Carbon dioxide (CAS 124-38-9) Distillates (petroleum), hydrotreated light (CAS 64742-47-8) Methyl salicylate (CAS 119-36-8) US. Rhode Island RTK None. US. California Proposition 65 California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material is not known to contain any chemicals currently listed as carcinogens or reproductive toxins. Volatile organic compounds (VOC) regulations EPA VOC content (40 CFR 51.100(s)) 97.1 % Consumer products (40 CFR 59, Subpt. C) Not regulated State Consumer products This product is regulated as a Multi-Purpose Lubricant. This product is compliant for use in all 50 states. VOC content (CA) 0 % VOC content (OTC) 0 % 7 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US International Inventories Country(s) or region Inventory name On inventory (yes/no)* YesAustralia Australian Inventory of Chemical Substances (AICS) NoCanada Domestic Substances List (DSL) YesCanada Non-Domestic Substances List (NDSL) YesChina Inventory of Existing Chemical Substances in China (IECSC) NoEurope European Inventory of Existing Commercial Chemical Substances (EINECS) NoEurope European List of Notified Chemical Substances (ELINCS) NoJapan Inventory of Existing and New Chemical Substances (ENCS) YesKorea Existing Chemicals List (ECL) NoNew Zealand New Zealand Inventory NoPhilippines Philippine Inventory of Chemicals and Chemical Substances (PICCS) YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory *A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information, including date of preparation or last revision Issue date 02-07-2014 Prepared by Allison Cho Version # 01 Further information CRC # 462F HMIS? ratings Health: 1* Flammability: 4 Physical hazard: 0 Personal protection: B NFPA ratings Health: 1 Flammability: 4 Instability: 0 Disclaimer The information contained in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. This information is accurate to the best of CRC Industries' knowledge or obtained from sources believed by CRC to be accurate. Before using any product, read all warnings and directions on the label. For further clarification of any information contained on this (M)SDS consult your supervisor, a health & safety professional, or CRC Industries. 8 / 8 Material name: Power Lube? Multi-Purpose Lubricant 1792 Version #: 01 Issue date: 02-07-2014 SDS US