SAFETY DATA SHEET 1. Identification Brakleen? Brake Parts Cleaner - Non-ChlorinatedProduct identifier Other means of identification 05084Product code Brake cleanerRecommended use None known.Recommended restrictions Manufacturer/Importer/Supplier/Distributor information Manufactured or sold by: Company name CRC Industries, Inc. Address 885 Louis Dr. Warminster, PA 18974 US Telephone General Information 215-674-4300 Technical Assistance 800-521-3168 Customer Service 800-272-4620 24-Hour Emergency 800-424-9300 (US) (CHEMTREC) 703-527-3887 (International) Website www.crcindustries.com 2. Hazard(s) identification Category 1Flammable aerosolsPhysical hazards Compressed gasGases under pressure Category 3Acute toxicity, oralHealth hazards Category 4Acute toxicity, dermal Category 4Acute toxicity, inhalation Category 2Skin corrosion/irritation Category 2ASerious eye damage/eye irritation Category 2Reproductive toxicity Category 1Specific target organ toxicity, single exposure Category 3 narcotic effectsSpecific target organ toxicity, single exposure Category 2Specific target organ toxicity, repeated exposure Category 1Aspiration hazard Category 2Hazardous to the aquatic environment, acute hazard Environmental hazards Category 2Hazardous to the aquatic environment, long-term hazard Not classified.OSHA defined hazards Label elements Signal word Danger 1 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US Hazard statement Extremely flammable aerosol. Contains gas under pressure; may explode if heated. Toxic if swallowed. May be fatal if swallowed and enters airways. Harmful in contact with skin. Causes skin irritation. Causes serious eye irritation. Harmful if inhaled. May cause respiratory irritation. May cause drowsiness or dizziness. May cause damage to organs (brain, kideys, liver, lungs) through prolonged or repeated exposure. Suspected of damaging fertility or the unborn child. Causes damage to organs (eyes) by ingestion. Toxic to aquatic life. Toxic to aquatic life with long lasting effects. Precautionary statement Prevention Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not spray on an open flame or other ignition source. Do not apply while equipment is energized. Pressurized container: Do not pierce or burn, even after use. Extinguish all flames, pilot lights and heaters. Vapors will accumulate readily and may ignite. Use only with adequate ventilation; maintain ventilation during use and until all vapors are gone. Open doors and windows or use other means to ensure a fresh air supply during use and while product is drying. If you experience any symptoms listed on this label, increase ventilation or leave the area. Do not breathe mist or vapor. Wash thoroughly after handling. Do not eat, drink or smoke when using this product. Wear protective gloves/protective clothing/eye protection/face protection. Avoid release to the environment. Response If swallowed: Immediately call a poison center/doctor. Rinse mouth. Do NOT induce vomiting. If on skin: Wash with plenty of water. If skin irritation occurs: Get medical attention. Take off contaminated clothing and wash before reuse. If inhaled: Remove person to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical attention. If exposed: Call a poison center/doctor. If exposed or concerned: Get medical attention. Collect spillage. Storage Store in a well-ventilated place. Store locked up. Protect from sunlight. Do not expose to temperatures exceeding 50?C/122?F. Exposure to high temperature may cause can to burst. Disposal Dispose of contents/container in accordance with local/regional/national regulations. Hazard(s) not otherwise classified (HNOC) Static accumulating flammable liquid can become electrostatically charged even in bonded and grounded equipment. Sparks may ignite liquid and vapor. May cause flash fire or explosion. 3. Composition/information on ingredients Mixtures CAS number %Common name and synonymsChemical name 67-64-1 40 - 50Acetone 67-56-1 10 - 20Methanol 124-38-9 5 - 10Carbon dioxide 142-82-5 5 - 10n-Heptane 108-88-3 5 - 10Toluene 589-34-4 3 - 53-Methylhexane 108-87-2 3 - 5Methylcyclohexane 64742-49-0 3 - 5Naphtha (petroleum), hydrotreated light 110-82-7 1 - 3Cyclohexane Specific chemical identity and/or percentage of composition has been withheld as a trade secret. 4. First-aid measures Remove victim to fresh air and keep at rest in a position comfortable for breathing. Oxygen or artificial respiration if needed. Call a POISON CENTER or doctor/physician if you feel unwell. Inhalation Take off immediately all contaminated clothing. Rinse skin with water/shower. If skin irritation occurs: Get medical advice/attention. Wash contaminated clothing before reuse. Skin contact Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists. Eye contact Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If vomiting occurs, keep head low so that stomach content doesn't get into the lungs. Do not use mouth-to-mouth method if victim ingested the substance. Induce artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device. Ingestion 2 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US May cause drowsiness and dizziness. Headache. Nausea, vomiting. Aspiration may cause pulmonary edema and pneumonitis. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. May cause respiratory irritation. Skin irritation. May cause redness and pain. Prolonged exposure may cause chronic effects. Most important symptoms/effects, acute and delayed Provide general supportive measures and treat symptomatically. Thermal burns: Flush with water immediately. While flushing, remove clothes which do not adhere to affected area. Call an ambulance. Continue flushing during transport to hospital. Keep victim warm. Keep victim under observation. Symptoms may be delayed. Indication of immediate medical attention and special treatment needed Take off all contaminated clothing immediately. IF exposed or concerned: Get medical advice/attention. Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Show this safety data sheet to the doctor in attendance. Wash contaminated clothing before reuse. General information 5. Fire-fighting measures Alcohol resistant foam. Water fog. Carbon dioxide (CO2). Dry chemical powder, carbon dioxide, sand or earth may be used for small fires only. Suitable extinguishing media Do not use water jet as an extinguisher, as this will spread the fire.Unsuitable extinguishing media Contents under pressure. Pressurized container may rupture when exposed to heat or flame. This product is a poor conductor of electricity and can become electrostatically charged. If sufficient charge is accumulated, ignition of flammable mixtures can occur. Static electricity accumulation may be significantly increased by the presence of small quantities of water or other contaminants. Material will float and may ignite on surface of water. During fire, gases hazardous to health may be formed. Specific hazards arising from the chemical Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA. Special protective equipment and precautions for firefighters Fire-fighting equipment/instructions In case of fire: Stop leak if safe to do so. Move containers from fire area if you can do so without risk. Containers should be cooled with water to prevent vapor pressure build up. Extremely flammable aerosol. Contents under pressure. Pressurized container may rupture when exposed to heat or flame. General fire hazards 6. Accidental release measures Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Remove all possible sources of ignition in the surrounding area. Many gases are heavier than air and will spread along ground and collect in low or confined areas (sewers, basements, tanks). Wear appropriate protective equipment and clothing during clean-up. Do not breathe mist or vapor. Emergency personnel need self-contained breathing equipment. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Ventilate closed spaces before entering them. Use appropriate containment to avoid environmental contamination. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS. Personal precautions, protective equipment and emergency procedures Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. This product is miscible in water. Stop the flow of material, if this is without risk. Prevent product from entering drains. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. For waste disposal, see section 13 of the SDS. Methods and materials for containment and cleaning up Avoid release to the environment. Prevent further leakage or spillage if safe to do so. Avoid discharge into drains, water courses or onto the ground. Inform appropriate managerial or supervisory personnel of all environmental releases. Use appropriate containment to avoid environmental contamination. Environmental precautions 3 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US 7. Handling and storage Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Minimize fire risks from flammable and combustible materials (including combustible dust and static accumulating liquids) or dangerous reactions with incompatible materials. Pressurized container: Do not pierce or burn, even after use. Do not use if spray button is missing or defective. Do not spray on a naked flame or any other incandescent material. Do not smoke while using or until sprayed surface is thoroughly dry. Do not cut, weld, solder, drill, grind, or expose containers to heat, flame, sparks, or other sources of ignition. Use caution around energized equipment. The metal container will conduct electricity if it contacts a live source. This may result in injury to the user from electrical shock and/or flash fire. Do not breathe mist or vapor. Avoid contact with eyes, skin, and clothing. Avoid prolonged exposure. Do not taste or swallow. When using, do not eat, drink or smoke. Pregnant or breastfeeding women must not handle this product. Use only outdoors or in a well-ventilated area. Wear appropriate personal protective equipment. Wash hands thoroughly after handling. Observe good industrial hygiene practices. Avoid release to the environment. Wash contaminated clothing before reuse. For product usage instructions, please see the product label. Precautions for safe handling Level 3 Aerosol. Pressurized container. Protect from sunlight and do not expose to temperatures exceeding 50?C/122 ?F. Do not puncture, incinerate or crush. Do not handle or store near an open flame, heat or other sources of ignition. This material can accumulate static charge which may cause spark and become an ignition source. Avoid spark promoters. These alone may be insufficient to remove static electricity. Store in a well-ventilated place. Store away from incompatible materials (see Section 10 of the SDS). Conditions for safe storage, including any incompatibilities 8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) ValueComponents Type PEL 2400 mg/m3Acetone (CAS 67-64-1) 1000 ppm PEL 9000 mg/m3Carbon dioxide (CAS 124-38-9) 5000 ppm PEL 1050 mg/m3Cyclohexane (CAS 110-82-7) 300 ppm PEL 260 mg/m3Methanol (CAS 67-56-1) 200 ppm PEL 2000 mg/m3Methylcyclohexane (CAS 108-87-2) 500 ppm PEL 2000 mg/m3n-Heptane (CAS 142-82-5) 500 ppm US. OSHA Table Z-2 (29 CFR 1910.1000) ValueComponents Type Ceiling 300 ppmToluene (CAS 108-88-3) TWA 200 ppm US. ACGIH Threshold Limit Values ValueComponents Type STEL 500 ppm3-Methylhexane (CAS 589-34-4) TWA 400 ppm STEL 500 ppmAcetone (CAS 67-64-1) TWA 250 ppm STEL 30000 ppmCarbon dioxide (CAS 124-38-9) TWA 5000 ppm TWA 100 ppmCyclohexane (CAS 110-82-7) STEL 250 ppmMethanol (CAS 67-56-1) TWA 200 ppm 4 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US US. ACGIH Threshold Limit Values ValueComponents Type STEL 500 ppmMethylcyclohexane (CAS 108-87-2) TWA 400 ppm STEL 500 ppmn-Heptane (CAS 142-82-5) TWA 400 ppm TWA 20 ppmToluene (CAS 108-88-3) US. NIOSH: Pocket Guide to Chemical Hazards ValueComponents Type TWA 590 mg/m3Acetone (CAS 67-64-1) 250 ppm STEL 54000 mg/m3Carbon dioxide (CAS 124-38-9) 30000 ppm TWA 9000 mg/m3 5000 ppm TWA 1050 mg/m3Cyclohexane (CAS 110-82-7) 300 ppm STEL 325 mg/m3Methanol (CAS 67-56-1) 250 ppm TWA 260 mg/m3 200 ppm TWA 1600 mg/m3Methylcyclohexane (CAS 108-87-2) 400 ppm Ceiling 1800 mg/m3n-Heptane (CAS 142-82-5) 440 ppm TWA 350 mg/m3 85 ppm STEL 560 mg/m3Toluene (CAS 108-88-3) 150 ppm TWA 375 mg/m3 100 ppm Biological limit values ACGIH Biological Exposure Indices ValueComponents Determinant Specimen Sampling Time 25 mg/l Acetone Urine *Acetone (CAS 67-64-1) 15 mg/l Methanol Urine *Methanol (CAS 67-56-1) 0.3 mg/g o-Cresol, with hydrolysis Creatinine in urine *Toluene (CAS 108-88-3) 0.03 mg/l Toluene Urine * 0.02 mg/l Toluene Blood * * - For sampling details, please see the source document. Exposure guidelines US - California OELs: Skin designation Methanol (CAS 67-56-1) Can be absorbed through the skin. Toluene (CAS 108-88-3) Can be absorbed through the skin. US - Minnesota Haz Subs: Skin designation applies Methanol (CAS 67-56-1) Skin designation applies. Toluene (CAS 108-88-3) Skin designation applies. US - Tennessee OELs: Skin designation Methanol (CAS 67-56-1) Can be absorbed through the skin. US ACGIH Threshold Limit Values: Skin designation Methanol (CAS 67-56-1) Can be absorbed through the skin. US NIOSH Pocket Guide to Chemical Hazards: Skin designation Methanol (CAS 67-56-1) Can be absorbed through the skin. 5 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level. Eye wash facilities and emergency shower should be available when handling this product. Appropriate engineering controls Individual protection measures, such as personal protective equipment Wear safety glasses with side shields (or goggles).Eye/face protection Skin protection Wear protective gloves such as: Nitrile. Neoprene. Polyvinyl alcohol (PVA).Hand protection Wear appropriate chemical resistant clothing.Other If engineering controls are not feasible or if exposure exceeds the applicable exposure limits, use a NIOSH-approved cartridge respirator with an organic vapor cartridge. Use a self-contained breathing apparatus in confined spaces and for emergencies. Air monitoring is needed to determine actual employee exposure levels. Respiratory protection Wear appropriate thermal protective clothing, when necessary.Thermal hazards When using do not smoke. Keep away from food and drink. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. General hygiene considerations 9. Physical and chemical properties Appearance Liquid.Physical state Aerosol.Form Clear.Color Solvent.Odor Odor threshold Not available. pH Not available. Melting point/freezing point -195.9 ?F (-126.6 ?C) estimated Initial boiling point and boiling range 132.9 ?F (56.1 ?C) estimated Flash point < 0 ?F (< -17.8 ?C) Tag Closed Cup Evaporation rate Fast. Not available.Flammability (solid, gas) Upper/lower flammability or explosive limits Flammability limit - lower (%) 1.1 % estimated Flammability limit - upper (%) 36 % estimated Vapor pressure 5157.4 hPa estimated Vapor density > 1 (air = 1) Relative density 0.84 estimated Solubility (water) Slightly soluble. Partition coefficient (n-octanol/water) Not available. Auto-ignition temperature 539.6 ?F (282 ?C) estimated Decomposition temperature Not available. Viscosity (kinematic) Not available. Percent volatile 91.2 % estimated 10. Stability and reactivity The product is stable and non-reactive under normal conditions of use, storage and transport.Reactivity Material is stable under normal conditions.Chemical stability No dangerous reaction known under conditions of normal use.Possibility of hazardous reactions 6 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US Heat, flames and sparks. Contact with incompatible materials.Conditions to avoid Acids. Alkalies. Amines. Ammonia. Halogens. Aluminum. Magnesium. Zinc. Peroxides. Strong oxidizing agents. Reducing agents. Incompatible materials Carbon oxides. Formaldehyde.Hazardous decomposition products 11. Toxicological information Information on likely routes of exposure Inhalation Harmful if inhaled. May cause damage to organs through prolonged or repeated exposure by inhalation. May cause drowsiness and dizziness. Headache. Nausea, vomiting. Skin contact Harmful in contact with skin. Causes skin irritation. Eye contact Causes serious eye irritation. Ingestion Toxic if swallowed. Even small amounts (30-250 ml methanol) may be fatal. Symptoms are stomach ache, nausea, vomiting, dullness, visual disorder and blindness. Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious chemical pneumonia. Symptoms related to the physical, chemical and toxicological characteristics Headache. May cause drowsiness and dizziness. Nausea, vomiting. Aspiration may cause pulmonary edema and pneumonitis. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. May cause respiratory irritation. Skin irritation. May cause redness and pain. Information on toxicological effects Acute toxicity May be fatal if swallowed and enters airways. Harmful if inhaled. Harmful in contact with skin. Narcotic effects. May cause respiratory irritation. Test ResultsProduct Species Brakleen? Brake Parts Cleaner - Non-Chlorinated Dermal Acute LD50 Rabbit 7388 mg/kg estimated Inhalation LC50 Rat 27188 ppm, 4 hours estimated 68 mg/l, 4 Hours estimated Oral * Estimates for product may be based on additional component data not shown. LD50 Human 305 mg/kg estimated Causes skin irritation.Skin corrosion/irritation Causes serious eye irritation.Serious eye damage/eye irritation Respiratory sensitization Not a respiratory sensitizer. This product is not expected to cause skin sensitization.Skin sensitization No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. Germ cell mutagenicity Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. IARC Monographs. Overall Evaluation of Carcinogenicity Toluene (CAS 108-88-3) 3 Not classifiable as to carcinogenicity to humans. US. National Toxicology Program (NTP) Report on Carcinogens Not available. Suspected of damaging fertility. Suspected of damaging the unborn child.Reproductive toxicity Specific target organ toxicity - single exposure Causes damage to organs: Eyes. May cause respiratory irritation. May cause drowsiness and dizziness. Specific target organ toxicity - repeated exposure May cause damage to organs through prolonged or repeated exposure: Liver. Kidneys. Brain. Lungs. Aspiration hazard May be fatal if swallowed and enters airways. If aspirated into lungs during swallowing or vomiting, may cause chemical pneumonia, pulmonary injury or death. Chronic effects May cause damage to organs through prolonged or repeated exposure. 7 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US 12. Ecological information Toxic to aquatic life with long lasting effects.Ecotoxicity Product Test ResultsSpecies Brakleen? Brake Parts Cleaner - Non-Chlorinated Aquatic Acute EC50Crustacea 25566.5273 mg/l, 48 hours estimatedDaphnia LC50Fish 37.5792 mg/l, 96 hours estimatedFish Components Test ResultsSpecies Acetone (CAS 67-64-1) Aquatic EC50Crustacea 10294 - 17704 mg/l, 48 hoursWater flea (Daphnia magna) LC50Fish 4740 - 6330 mg/l, 96 hoursRainbow trout,donaldson trout (Oncorhynchus mykiss) Cyclohexane (CAS 110-82-7) Aquatic LC50Fish 23.03 - 42.07 mg/l, 96 hoursFathead minnow (Pimephales promelas) Methanol (CAS 67-56-1) Aquatic LC50Fish 18000 - 20000 mg/l, 96 hoursRainbow trout,donaldson trout (Oncorhynchus mykiss) Acute EC50Crustacea > 10000 mg/l, 48 hoursWater flea (Daphnia magna) LC50Fish 18000 - 20000 mg/l, 96 hoursRainbow trout,donaldson trout (Oncorhynchus mykiss) Methylcyclohexane (CAS 108-87-2) Aquatic LC50Fish 5.8 mg/l, 96 hoursStriped bass (Morone saxatilis) n-Heptane (CAS 142-82-5) Aquatic Acute LC50Fish 2.1 - 2.98 mg/l, 96 hoursFathead minnow (Pimephales promelas) Toluene (CAS 108-88-3) Aquatic EC50Crustacea 5.46 - 9.83 mg/l, 48 hoursWater flea (Daphnia magna) * Estimates for product may be based on additional component data not shown. LC50Fish 8.11 mg/l, 96 hoursCoho salmon,silver salmon (Oncorhynchus kisutch) No data is available on the degradability of this product. Persistence and degradability Bioaccumulative potential Partition coefficient n-octanol / water (log Kow) Acetone -0.24 Cyclohexane 3.44 Methanol -0.77 Methylcyclohexane 3.61 n-Heptane 4.66 Toluene 2.73 No data available.Mobility in soil Other adverse effects No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. 8 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US 13. Disposal considerations This material and its container must be disposed of as hazardous waste. Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Do not allow this material to drain into sewers/water supplies. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose in accordance with all applicable regulations. Disposal of waste from residues / unused products D001: Waste Flammable material with a flash point <140 F F003: Waste Non-halogenated Solvent - Spent Non-halogenated Solvent F005: Waste Non-halogenated Solvent - Spent Non-halogenated Solvent Hazardous waste code Since emptied containers may retain product residue, follow label warnings even after container is emptied. Empty containers should be taken to an approved waste handling site for recycling or disposal. Contaminated packaging 14. Transport information DOT UN1950UN number Aerosols, flammable, Limited QuantityUN proper shipping name 2.1Class Transport hazard class(es) 6.1(PGIII)Subsidiary risk 2.1Label(s) Not applicable.Packing group Read safety instructions, SDS and emergency procedures before handling.Special precautions for user N82Special provisions 306Packaging exceptions NonePackaging non bulk NonePackaging bulk IATA UN1950UN number Aerosols, flammable, containing substances in Division 6.1, Packing Group IIIUN proper shipping name 2.1Class Transport hazard class(es) 6.1(PGIII)Subsidiary risk Not applicable.Packing group No.Environmental hazards 10PERG Code Read safety instructions, SDS and emergency procedures before handling.Special precautions for user Allowed with restrictions.Passenger and cargo aircraft Other information Allowed with restrictions.Cargo aircraft only IMDG UN1950UN number AEROSOLSUN proper shipping name 2Class Transport hazard class(es) 6.1(PGIII)Subsidiary risk Not applicable.Packing group No.Environmental hazards Not available.EmS Read safety instructions, SDS and emergency procedures before handling.Special precautions for user 15. Regulatory information This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. US federal regulations TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. SARA 304 Emergency release notification Not regulated. 9 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US US EPCRA (SARA Title III) Section 313 - Toxic Chemical: Listed substance Cyclohexane (CAS 110-82-7) Methanol (CAS 67-56-1) Toluene (CAS 108-88-3) CERCLA Hazardous Substance List (40 CFR 302.4) Acetone (CAS 67-64-1) Cyclohexane (CAS 110-82-7) Methanol (CAS 67-56-1) Toluene (CAS 108-88-3) CERCLA Hazardous Substances: Reportable quantity Acetone (CAS 67-64-1) 5000 LBS Cyclohexane (CAS 110-82-7) 1000 LBS Methanol (CAS 67-56-1) 5000 LBS Toluene (CAS 108-88-3) 1000 LBS Spills or releases resulting in the loss of any ingredient at or above its RQ require immediate notification to the National Response Center (800-424-8802) and to your Local Emergency Planning Committee. Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Methanol (CAS 67-56-1) Toluene (CAS 108-88-3) Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130) Not regulated. Not regulated.Safe Drinking Water Act (SDWA) Drug Enforcement Administration (DEA). List 2, Essential Chemicals (21 CFR 1310.02(b) and 1310.04(f)(2) and Chemical Code Number Acetone (CAS 67-64-1) 6532 Toluene (CAS 108-88-3) 6594 Drug Enforcement Administration (DEA). List 1 & 2 Exempt Chemical Mixtures (21 CFR 1310.12(c)) Acetone (CAS 67-64-1) 35 %WV Toluene (CAS 108-88-3) 35 %WV DEA Exempt Chemical Mixtures Code Number Acetone (CAS 67-64-1) 6532 Toluene (CAS 108-88-3) 594 FEMA Priority Substances Respiratory Health and Safety in the Flavor Manufacturing Workplace Acetone (CAS 67-64-1) Low priority Not regulated.Food and Drug Administration (FDA) Superfund Amendments and Reauthorization Act of 1986 (SARA) Immediate Hazard - Yes Delayed Hazard - Yes Fire Hazard - Yes Pressure Hazard - Yes Reactivity Hazard - No Section 311/312 Hazard categories NoSARA 302 Extremely hazardous substance US state regulations US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, 69502.3, subd. (a)) Acetone (CAS 67-64-1) Methanol (CAS 67-56-1) Naphtha (petroleum), hydrotreated light (CAS 64742-49-0) Toluene (CAS 108-88-3) US. New Jersey Worker and Community Right-to-Know Act 3-Methylhexane (CAS 589-34-4) Acetone (CAS 67-64-1) Carbon dioxide (CAS 124-38-9) Methylcyclohexane (CAS 108-87-2) n-Heptane (CAS 142-82-5) US. Massachusetts RTK - Substance List 3-Methylhexane (CAS 589-34-4) 10 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US Acetone (CAS 67-64-1) Carbon dioxide (CAS 124-38-9) Cyclohexane (CAS 110-82-7) Methanol (CAS 67-56-1) Methylcyclohexane (CAS 108-87-2) n-Heptane (CAS 142-82-5) Toluene (CAS 108-88-3) US. California Controlled Substances. CA Department of Justice (California Health and Safety Code Section 11100) Not listed. US. Rhode Island RTK Acetone (CAS 67-64-1) Cyclohexane (CAS 110-82-7) Methanol (CAS 67-56-1) Toluene (CAS 108-88-3) US. New Jersey Worker and Community Right-to-Know Act Cyclohexane (CAS 110-82-7) Methanol (CAS 67-56-1) Toluene (CAS 108-88-3) US. Pennsylvania Worker and Community Right-to-Know Law Acetone (CAS 67-64-1) Cyclohexane (CAS 110-82-7) Methanol (CAS 67-56-1) Toluene (CAS 108-88-3) Benzene (CAS 71-43-2) 3-Methylhexane (CAS 589-34-4) Carbon dioxide (CAS 124-38-9) Methylcyclohexane (CAS 108-87-2) n-Heptane (CAS 142-82-5) US. California Proposition 65 WARNING: This product contains a chemical known to the State of California to cause cancer and birth defects or other reproductive harm. US - California Proposition 65 - CRT: Listed date/Carcinogenic substance Benzene (CAS 71-43-2) Listed: February 27, 1987 Cumene (CAS 98-82-8) Listed: April 6, 2010 Ethanal (CAS 75-07-0) Listed: April 1, 1988 Ethylbenzene (CAS 100-41-4) Listed: June 11, 2004 Naphthalene (CAS 91-20-3) Listed: April 19, 2002 US - California Proposition 65 - CRT: Listed date/Developmental toxin Benzene (CAS 71-43-2) Listed: December 26, 1997 Methanol (CAS 67-56-1) Listed: March 16, 2012 Toluene (CAS 108-88-3) Listed: January 1, 1991 US - California Proposition 65 - CRT: Listed date/Male reproductive toxin Benzene (CAS 71-43-2) Listed: December 26, 1997 Volatile organic compounds (VOC) regulations EPA VOC content (40 CFR 51.100(s)) 43.8 % Not regulatedConsumer products (40 CFR 59, Subpt. C) State This product is regulated as a Brake Cleaner. This product is not compliant to be sold for use in California and the following counties in Utah: Box Elder, Cache, Davis, Salt Lake, Tooele, Utah and Weber. This product is compliant in all other states. Consumer products VOC content (CA) 43.8 % VOC content (OTC) 43.8 % International Inventories Country(s) or region Inventory name On inventory (yes/no)* NoAustralia Australian Inventory of Chemical Substances (AICS) NoCanada Domestic Substances List (DSL) 11 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US Country(s) or region Inventory name On inventory (yes/no)* YesCanada Non-Domestic Substances List (NDSL) YesChina Inventory of Existing Chemical Substances in China (IECSC) YesEurope European Inventory of Existing Commercial Chemical Substances (EINECS) NoEurope European List of Notified Chemical Substances (ELINCS) YesJapan Inventory of Existing and New Chemical Substances (ENCS) YesKorea Existing Chemicals List (ECL) YesNew Zealand New Zealand Inventory YesPhilippines Philippine Inventory of Chemicals and Chemical Substances (PICCS) YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory *A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information, including date of preparation or last revision 04-28-2015Issue date 12-17-2015Revision date Allison ChoPrepared by Version # 03 CRC # 991Further information Health: 2* Flammability: 4 Physical hazard: 0 Personal protection: B HMIS? ratings Health: 2 Flammability: 4 Instability: 0 NFPA ratings NFPA ratings 02 4 The information contained in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. This information is accurate to the best of CRC Industries' knowledge or obtained from sources believed by CRC to be accurate. Before using any product, read all warnings and directions on the label. For further clarification of any information contained on this (M)SDS consult your supervisor, a health & safety professional, or CRC Industries. Disclaimer 12 / 12 Material name: Brakleen? Brake Parts Cleaner - Non-Chlorinated 05084 Version #: 03 Revision date: 12-17-2015 Issue date: 04-28-2015 SDS US