1. IDENTIFICATION Product identifier Product Name NICKEL ANTI-SEIZE LUBRICANT 1LB BB Other means of identification Product Code 77164 Synonyms None Recommended use of the chemical and restrictions on use Recommended Use Lubricant Uses advised against No information available Details of the supplier of the safety data sheet Company Phone Number 1-87-Permatex (877) 376-2839 24 Hour Emergency Phone Number Chem-Tel: 800-255-3924 International Emergency: 00+1+ 813-248-0585 Contract Number: MIS0003453 E-mail address This email address is being protected from spambots. You need JavaScript enabled to view it. 2. HAZARDS IDENTIFICATION Classification OSHA Regulatory Status This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) Skin sensitization Category 1 Carcinogenicity Category 2 Label elements Emergency Overview _____________________________________________________________________________________________ Page 1 / 9 Distributor ITW Permatex Canada 35 Brownridge Road, Unit 1 Halton Hills, ON Canada L7G 0C6 Telephone: (800) 924-6994 May cause an allergic skin reaction Suspected of causing cancer Revision Date 12-Dec-2014 SAFETY DATA SHEET Version 1 Manufacturer Address ITW Permatex 10 Columbus Blvd. Hartford, CT 06106 USA Warning _____________________________________________________________________________________________ Precautionary Statements - Prevention Obtain special instructions before use Do not handle until all safety precautions have been read and understood Use personal protective equipment as required Avoid breathing mists or vapors Wear protective gloves Contaminated work clothing should not be allowed out of the workplace Precautionary Statements - Response IF exposed or concerned: Get medical advice/attention Specific treatment (see supplemental first aid instructions on this label) IF ON SKIN: Wash with plenty of soap and water If skin irritation or rash occurs: Get medical advice/attention Wash contaminated clothing before reuse Precautionary Statements - Storage Store locked up Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable Other Information Toxic to aquatic life with long lasting effects. The classification as a carcinogen need not apply if it can be shown that the substance contains less than 3 % DMSO extract as measured by IP 346. This note applies only to certain complex oil derived substances in Annex I. No. Respirable dust. Unknown acute toxicity 34.5% of the mixture consists of ingredient(s) of unknown toxicity 3. COMPOSITION/INFORMATION ON INGREDIENTS substance(s) Chemical Name CAS No Weight-% Trade Secret DISTILLATES (PETROLEUM), SOLVENT-REFINED HEAVY NAPHTHENIC 64741-96-4 30 - 60 * GRAPHITE 7782-42-5 10 - 30 * NICKEL 7440-02-0 5 - 10 * ALUMINIUM POWDER 7429-90-5 1 - 5 * *The exact percentage (concentration) of composition has been withheld as a trade secret. 4. FIRST AID MEASURES Description of first aid measures General advice Get medical advice/attention if you feel unwell. _____________________________________________________________________________________________ Page 2 / 9 77164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB Revision Date 12-Dec-2014 Physical state Paste Odor Petroleum odorAppearance Silver _____________________________________________________________________________________________ Eye contact IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Skin contact IF ON SKIN:. Wash with soap and water. If skin irritation or rash occurs: Get medical advice/attention. Wash contaminated clothing before reuse. Inhalation IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. If symptoms persist, call a physician. Ingestion IF SWALLOWED:. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician. Self-protection of the first aider Use personal protective equipment as required. Avoid contact with skin, eyes or clothing. Most important symptoms and effects, both acute and delayed Symptoms See section 2 for more information. Indication of any immediate medical attention and special treatment needed Note to physicians Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Carbon dioxide (CO2), Dry chemical, Foam Unsuitable extinguishing media Water. Specific hazards arising from the chemical None in particular. Explosion data Sensitivity to Mechanical Impact None. Sensitivity to Static Discharge None. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Ensure adequate ventilation, especially in confined areas. Avoid contact with eyes and skin. Use personal protective equipment as required. Environmental precautions Environmental precautions Do not flush into surface water or sanitary sewer system. See Section 12 for additional ecological information. Methods and material for containment and cleaning up Methods for containment Prevent further leakage or spillage if safe to do so. Methods for cleaning up Ensure adequate ventilation. Soak up with inert absorbent material. Sweep up and shovel into suitable containers for disposal. _____________________________________________________________________________________________ Page 3 / 9 Revision Date 12-Dec-201477164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB _____________________________________________________________________________________________ Prevention of secondary hazards Clean contaminated objects and areas thoroughly observing environmental regulations. 7. HANDLING AND STORAGE Precautions for safe handling Advice on safe handling Handle in accordance with good industrial hygiene and safety practice. Avoid breathing vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling. Wash contaminated clothing before reuse. Use personal protective equipment as required. Conditions for safe storage, including any incompatibilities Storage Conditions Keep container tightly closed in a dry and well-ventilated place. Store locked up. Incompatible materials Strong oxidizing agents 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Exposure Guidelines . Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH GRAPHITE 7782-42-5 TWA: 2 mg/m3 respirable fraction all forms except graphite fibers TWA: 15 mg/m3 total dust synthetic TWA: 5 mg/m3 respirable fraction synthetic (vacated) TWA: 2.5 mg/m3 respirable dust natural (vacated) TWA: 10 mg/m3 total dust synthetic (vacated) TWA: 5 mg/m3 respirable fraction synthetic TWA: 15 mppcf natural IDLH: 1250 mg/m3 TWA: 2.5 mg/m3 natural respirable dust NICKEL 7440-02-0 TWA: 1.5 mg/m3 inhalable fraction TWA: 1 mg/m3 (vacated) TWA: 1 mg/m3 IDLH: 10 mg/m3 Ni TWA: 0.015 mg/m3 except Nickel carbonyl Ni ALUMINIUM POWDER 7429-90-5 TWA: 1 mg/m3 respirable fraction TWA: 15 mg/m3 total dust TWA: 5 mg/m3 respirable fraction (vacated) TWA: 5 mg/m3 Al Aluminum TWA: 5 mg/m3 Al NIOSH IDLH Immediately Dangerous to Life or Health Other Information Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Controls Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/face protection Wear safety glasses with side shields (or goggles). Skin and body protection Wear protective gloves and protective clothing. Respiratory protection Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as appropriate. General Hygiene Considerations Handle in accordance with good industrial hygiene and safety practice. Regular cleaning of equipment, work area and clothing is recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES _____________________________________________________________________________________________ Page 4 / 9 77164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB Revision Date 12-Dec-2014 _____________________________________________________________________________________________ Information on basic physical and chemical properties Physical state Paste Appearance Silver Odor Petroleum odor Odor threshold No information available Explosive properties No information available Oxidizing properties No information available Other Information Softening point No information available Molecular weight No information available VOC Content (%) 0 Density No information available Bulk density No information available 10. STABILITY AND REACTIVITY Reactivity Chemical stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. Hazardous polymerization Hazardous polymerization does not occur. Conditions to avoid Excessive heat. Incompatible materials Strong oxidizing agents Hazardous Decomposition Products Carbon oxides Metal oxides _____________________________________________________________________________________________ Page 5 / 9 No information available Evaporation rate < 1 Autoignition temperature No information available Revision Date 12-Dec-2014 Decomposition temperature No information available Butyl acetate = 1 Kinematic viscosity No information available Flammability (solid, gas) No information available Dynamic viscosity No information available Property Flammability Limit in Air Melting point / freezing point No information available Upper flammability limit: No information available Values Lower flammability limit: No information available Vapor pressure No information available Boiling point / boiling range No information available No data available Vapor density No information available Remarks ? Method Relative density 1.12 77164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB Flash point Water solubility Negligible > 204 ?C / > 400 ?F Solubility in other solvents No information available pH Partition coefficient No information available _____________________________________________________________________________________________ 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure Inhalation May cause irritation of respiratory tract. Eye contact Contact with eyes may cause irritation. May cause redness and tearing of the eyes. Skin contact May cause skin irritation and/or dermatitis. Repeated or prolonged skin contact may cause allergic reactions with susceptible persons. Ingestion Ingestion may cause irritation to mucous membranes. Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 NICKEL 7440-02-0 > 9000 mg/kg ( Rat ) - - Information on toxicological effects Symptoms No information available. Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization May cause sensitization by skin contact. Germ cell mutagenicity No information available. Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Chemical Name ACGIH IARC NTP OSHA DISTILLATES (PETROLEUM), SOLVENT-REFINED HEAVY NAPHTHENIC 64741-96-4 A2 Group 1 - X NICKEL 7440-02-0 - Group 1 Known X ACGIH (American Conference of Governmental Industrial Hygienists) A2 - Suspected Human Carcinogen IARC (International Agency for Research on Cancer) Group 1 - Carcinogenic to Humans NTP (National Toxicology Program) Known - Known Carcinogen OSHA (Occupational Safety and Health Administration of the US Department of Labor) X - Present Target Organ Effects Central Vascular System (CVS), Lungs, Nasal Cavities, Respiratory system, Skin. The following values are calculated based on chapter 3.1 of the GHS document . ATEmix (oral) 73761 mg/kg 12. ECOLOGICAL INFORMATION Ecotoxicity 37% of the mixture consists of components(s) of unknown hazards to the aquatic environment Chemical Name Algae/aquatic plants Fish Crustacea DISTILLATES (PETROLEUM), SOLVENT-REFINED HEAVY NAPHTHENIC 64741-96-4 - 5000: 96 h Oncorhynchus mykiss mg/L LC50 1000: 48 h Daphnia magna mg/L EC50 NICKEL 7440-02-0 0.18: 72 h Pseudokirchneriella subcapitata mg/L EC50 0.174 - 0.311: 96 h Pseudokirchneriella subcapitata mg/L EC50 static 100: 96 h Brachydanio rerio mg/L LC50 1.3: 96 h Cyprinus carpio mg/L LC50 semi-static 10.4: 96 h Cyprinus carpio mg/L LC50 static 100: 48 h Daphnia magna mg/L EC50 1: 48 h Daphnia magna mg/L EC50 Static _____________________________________________________________________________________________ Page 6 / 9 77164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB Revision Date 12-Dec-2014 _____________________________________________________________________________________________ Persistence and degradability No information available. Bioaccumulation No information available. Mobility No information available. Other adverse effects No information available 13. DISPOSAL CONSIDERATIONS Waste treatment methods Disposal of wastes Disposal should be in accordance with applicable regional, national and local laws and regulations. Contaminated packaging Do not reuse container. US EPA Waste Number Not applicable Chemical Name RCRA RCRA - Basis for Listing RCRA - D Series Wastes RCRA - U Series Wastes NICKEL 7440-02-0 - Included in waste streams: F006, F039 - - This product contains one or more substances that are listed with the State of California as a hazardous waste. Chemical Name California Hazardous Waste Status NICKEL 7440-02-0 Toxic powder Ignitable powder ALUMINIUM POWDER 7429-90-5 Ignitable powder 14. TRANSPORT INFORMATION DOT Proper shipping name: Not regulated IATA Proper shipping name: Not regulated IMDG Proper shipping name: Not regulated 15. REGULATORY INFORMATION International Inventories TSCA Complies DSL/NDSL Complies EINECS/ELINCS Complies ENCS Not Listed. Contains: Natural substance(s) IECSC Complies KECL Complies PICCS Complies AICS Complies Legend: _____________________________________________________________________________________________ Page 7 / 9 Revision Date 12-Dec-201477164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB _____________________________________________________________________________________________ TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 Chemical Name SARA 313 - Threshold Values % NICKEL - 7440-02-0 0.1 ALUMINIUM POWDER - 7429-90-5 1.0 SARA 311/312 Hazard Categories Acute health hazard Yes Chronic Health Hazard Yes Fire hazard No Sudden release of pressure hazard No Reactive Hazard No CWA (Clean Water Act) This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42) Chemical Name CWA - Reportable Quantities CWA - Toxic Pollutants CWA - Priority Pollutants CWA - Hazardous Substances NICKEL 7440-02-0 - X X - CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ) NICKEL 7440-02-0 100 lb - RQ 100 lb final RQ RQ 45.4 kg final RQ US State Regulations California Proposition 65 This product contains the following Proposition 65 chemicals Chemical Name California Proposition 65 NICKEL - 7440-02-0 Carcinogen U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania GRAPHITE 7782-42-5 X X X NICKEL 7440-02-0 X X X ALUMINIUM POWDER 7429-90-5 X X X U.S. EPA Label Information EPA Pesticide Registration Number Not applicable _____________________________________________________________________________________________ Page 8 / 9 HMIS NFPA Health hazards 2 Flammability 1 Physical hazards 0 Personal protection B Health hazards 2 77164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB Flammability 1 Instability 0 Revision Date 12-Dec-2014 - _____________________________________________________________________________________________ NFPA (National Fire Protection Association) HMIS (Hazardous Material Information System) Revision Date 12-Dec-2014 Disclaimer The information provided in this Material Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet _____________________________________________________________________________________________ Page 9 / 9 77164 - NICKEL ANTI-SEIZE LUBRICANT 1LB BB Revision Date 12-Dec-2014