SAFETY DATA SHEET Revision Date 03-Feb-2015 Version 1 1. IDENTIFICATION Product identifier Product Name GM 1052943 GASKET MAKER 50 ML Other means of identification Product Code 17139 Synonyms None Recommended use of the chemical and restrictions on use Recommended Use Sealant Uses advised against No information available Details of the supplier of the safety data sheet Company Phone Number 1-87-Permatex (877) 376-2839 24 Hour Emergency Phone Number Chem-Tel: 800-255-3924 International Emergency: 00+1+ 813-248-0585 Contract Number: MIS0003453 2. HAZARDS IDENTIFICATION Classification OSHA Regulatory Status This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) Acute toxicity - Oral Category 4 Acute toxicity - Inhalation (Dusts/Mists) Category 4 Skin corrosion/irritation Category 2 Serious eye damage/eye irritation Category 2 Skin sensitization Category 1 Specific target organ toxicity (repeated exposure) Category 2 Label elements Emergency Overview _____________________________________________________________________________________________ Manufacturer Address ITW Permatex 10 Columbus Blvd. Hartford, CT 06106 USA Distributor ITW Permatex Canada 35 Brownridge Road, Unit 1 Halton Hills, ON Canada L7G 0C6 Telephone: (800) 924-6994 Warning Page 1 / 9 Harmful if swallowed Harmful if inhaled Causes skin irritation Causes serious eye irritation May cause an allergic skin reaction May cause damage to organs through prolonged or repeated exposure 10-2007, 1052943 - ACDelco Gasket Maker Sealant _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 Precautionary Statements - Prevention Wash face, hands and any exposed skin thoroughly after handling Do not eat, drink or smoke when using this product Use only outdoors or in a well-ventilated area Wear protective gloves/protective clothing/eye protection/face protection Contaminated work clothing should not be allowed out of the workplace Do not breathe dust/fume/gas/mist/vapors/spray Precautionary Statements - Response Get medical advice/attention if you feel unwell IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention IF ON SKIN: Wash with plenty of soap and water Take off contaminated clothing and wash before reuse If skin irritation or rash occurs: Get medical advice/attention IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing Call a POISON CENTER or doctor/physician if you feel unwell IF SWALLOWED: Call a POISON CENTER or doctor/physician if you feel unwell Rinse mouth Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable Other Information Not applicable. Unknown acute toxicity 91.144% of the mixture consists of ingredient(s) of unknown toxicity 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance Chemical Name CAS No Weight-% Trade Secret POLYURETHANE METHACRYLATE RESIN (MIXTURE) _ 30 - 60 * POLYGLYCOL DIMETHACRYLATE 25852-47-5 10 - 30 * 2-HYDROXYETHYL METHACRYLATE 868-77-9 1 - 5 * DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 1 - 5 * ACRYLIC ACID 79-10-7 0.1 - 1 * *The exact percentage (concentration) of composition has been withheld as a trade secret. 4. FIRST AID MEASURES Description of first aid measures _____________________________________________________________________________________________ Appearance Red Page 2 / 9 Physical state Gel Odor Mild _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 General advice Get medical advice/attention if you feel unwell. Eye contact IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Skin contact IF ON SKIN:. Wash with soap and water. If skin irritation or rash occurs: Get medical advice/attention. Wash contaminated clothing before reuse. Inhalation IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. If symptoms persist, call a physician. Ingestion IF SWALLOWED. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Self-protection of the first aider Use personal protective equipment as required. Avoid contact with skin, eyes or clothing. Most important symptoms and effects, both acute and delayed Symptoms See section 2 for more information. Indication of any immediate medical attention and special treatment needed Note to physicians Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Carbon dioxide (CO2), Dry chemical, Foam Unsuitable extinguishing media None. Specific hazards arising from the chemical None in particular. Explosion data Sensitivity to Mechanical Impact None. Sensitivity to Static Discharge None. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Ensure adequate ventilation, especially in confined areas. Avoid contact with eyes and skin. Use personal protective equipment as required. Environmental precautions Environmental precautions Do not flush into surface water or sanitary sewer system. See Section 12 for additional ecological information. Methods and material for containment and cleaning up _____________________________________________________________________________________________ Methods for containment Prevent further leakage or spillage if safe to do so. Page 3 / 9 Methods for cleaning up Ensure adequate ventilation. Soak up with inert absorbent material. Sweep up and shovel into suitable containers for disposal. _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 Prevention of secondary hazards Clean contaminated objects and areas thoroughly observing environmental regulations. 7. HANDLING AND STORAGE Precautions for safe handling Advice on safe handling Handle in accordance with good industrial hygiene and safety practice. Avoid breathing vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling. Wash contaminated clothing before reuse. Conditions for safe storage, including any incompatibilities Storage Conditions Keep containers tightly closed in a dry, cool and well-ventilated place. Incompatible materials Strong oxidizing agents. Amines. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Exposure Guidelines . Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH ACRYLIC ACID 79-10-7 TWA: 2 ppm S* (vacated) TWA: 10 ppm (vacated) TWA: 30 mg/m3 (vacated) S* TWA: 2 ppm TWA: 6 mg/m3 NIOSH IDLH Immediately Dangerous to Life or Health Other Information Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Controls Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/face protection Wear safety glasses with side shields (or goggles). Skin and body protection Wear protective gloves and protective clothing. Respiratory protection Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as appropriate. General Hygiene Considerations Handle in accordance with good industrial hygiene and safety practice. 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Physical state Gel Appearance Red Odor Mild Odor threshold No information available Property Values 5HPDUNV????0HWKRG?? pH Does not apply _____________________________________________________________________________________________ Melting point / freezing point No information available Boiling point / boiling range Page 4 / 9 > 149 ?C / 300 ?F _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 Explosive properties No information available Oxidizing properties No information available Other Information Softening point No information available Molecular weight No information available VOC Content (%) 1.5% Density No information available Bulk density No information available 10. STABILITY AND REACTIVITY Reactivity Chemical stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. Conditions to avoid Excessive heat. Incompatible materials Strong oxidizing agents, Amines Hazardous Decomposition Products Carbon oxides 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure Inhalation May cause irritation of respiratory tract. Eye contact May cause redness and tearing of the eyes. Skin contact May cause skin irritation and/or dermatitis. Repeated or prolonged skin contact may cause allergic reactions with susceptible persons. Ingestion Ingestion may cause irritation to mucous membranes. Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 Flash point > 93 ?C / > 199 ?F Tag Closed Cup Evaporation rate No information available Flammability (solid, gas) No information available Flammability Limit in Air Upper flammability limit: No information available Lower flammability limit: No information available Vapor pressure <5 mm Hg @ 25?C Vapor density >1 Air = 1 Relative density 1.08-1.18 Water solubility No information available Solubility in other solvents No information available Partition coefficient No information available Autoignition temperature No information available Decomposition temperature No information available Kinematic viscosity _____________________________________________________________________________________________ No information available Dynamic viscosity No information available Page 5 / 9 No data available _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 2-HYDROXYETHYL METHACRYLATE 868-77-9 = 5050 mg/kg ( Rat ) > 3000 mg/kg ( Rabbit ) - DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 = 382 mg/kg ( Rat ) = 0.126 mL/kg ( Rabbit ) = 220 ppm ( Rat ) 4 h ACRYLIC ACID 79-10-7 = 193 mg/kg ( Rat ) = 33500 ?g/kg ( Rat ) = 280 ?L/kg ( Rabbit ) = 295 mg/kg ( Rabbit ) = 11.1 mg/L ( Rat ) 1 h = 3.6 mg/L ( Rat ) 4 h Information on toxicological effects Symptoms No information available. Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization No information available. Germ cell mutagenicity No information available. Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Chemical Name ACGIH IARC NTP OSHA ACRYLIC ACID 79-10-7 - Group 3 - - IARC (International Agency for Research on Cancer) Not classifiable as a human carcinogen Numerical measures of toxicity - Product Information The following values are calculated based on chapter 3.1 of the GHS document . ATEmix (oral) 1041 mg/kg ATEmix (dermal) 2141 mg/kg ATEmix (inhalation-dust/mist) 1.5 mg/l 12. ECOLOGICAL INFORMATION Ecotoxicity None known 90.186% of the mixture consists of components(s) of unknown hazards to the aquatic environment Chemical Name Algae/aquatic plants Fish Crustacea 2-HYDROXYETHYL METHACRYLATE 868-77-9 - 213 - 242: 96 h Pimephales promelas mg/L LC50 flow-through 227: 96 h Pimephales promelas mg/L LC50 - DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 - 3.9: 96 h Oncorhynchus mykiss mg/L LC50 static 7: 24 h Daphnia magna mg/L EC50 ACRYLIC ACID 79-10-7 0.17: 96 h Pseudokirchneriella subcapitata mg/L EC50 0.04: 72 h Desmodesmus subspicatus mg/L EC50 222: 96 h Brachydanio rerio mg/L LC50 semi-static 95: 48 h Daphnia magna mg/L EC50 270: 24 h Daphnia magna mg/L LC50 Static Persistence and degradability No information available. Bioaccumulation No information available. Mobility No information available. Chemical Name Partition coefficient _____________________________________________________________________________________________ 2-HYDROXYETHYL METHACRYLATE 868-77-9 0.47 ACRYLIC ACID 79-10-7 0.38 - 0.46 Page 6 / 9 _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 Other adverse effects No information available 13. DISPOSAL CONSIDERATIONS Waste treatment methods Disposal of wastes Disposal should be in accordance with applicable regional, national and local laws and regulations. Contaminated packaging Do not reuse container. US EPA Waste Number Not applicable Chemical Name RCRA RCRA - Basis for Listing RCRA - D Series Wastes RCRA - U Series Wastes DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 - - - U096 ACRYLIC ACID 79-10-7 - - - U008 This product contains one or more substances that are listed with the State of California as a hazardous waste. Chemical Name California Hazardous Waste Status DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 Toxic Ignitable 14. TRANSPORT INFORMATION DOT Proper shipping name Not regulated TDG Proper shipping name Not regulated ICAO (air) Proper shipping name Not regulated IATA Proper shipping name Not regulated IMDG Proper shipping name Not regulated 15. REGULATORY INFORMATION International Inventories TSCA Complies DSL/NDSL Complies EINECS/ELINCS Does not comply ENCS Complies IECSC Complies KECL Complies _____________________________________________________________________________________________ PICCS Complies AICS Complies Page 7 / 9 _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 Chemical Name SARA 313 - Threshold Values % DIMETHYLBENZYL HYDROPEROXIDE - 80-15-9 1.0 SARA 311/312 Hazard Categories Acute health hazard Yes Chronic Health Hazard Yes Fire hazard No Sudden release of pressure hazard No Reactive Hazard No CWA (Clean Water Act) This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42) CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ) DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 10 lb - RQ 10 lb final RQ RQ 4.54 kg final RQ ACRYLIC ACID 79-10-7 5000 lb - RQ 5000 lb final RQ RQ 2270 kg final RQ US State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 X X X ACRYLIC ACID 79-10-7 X X X 1,4-NAPHTHOQUINONE 130-15-4 X X X U.S. EPA Label Information EPA Pesticide Registration Number Not applicable NFPA (National Fire Protection Association) HMIS (Hazardous Material Information System) NFPA Health hazards 2 Flammability 2 Instability 0 _____________________________________________________________________________________________ - HMIS Health hazards 2 Flammability 2 Page 8 / 9 Physical hazards 0 Personal protection B _____________________________________________________________________________________________ 17139 - GM 1052943 GASKET MAKER 50 ML Revision Date 03-Feb-2015 Revision Date 03-Feb-2015 _____________________________________________________________________________________________ Disclaimer The information provided in this Material Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. Page 9 / 9 End of Safety Data Sheet