1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING 1.1 Product Identifier Product Name: A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges Other means of identification Product Code: 3440025-062 Synonyms Not available 1.2 Recommended use of the chemical and restrictions on use Recommended Use Refrigerant Oil Uses advised against No information available 1.3. Details of the supplier of the safety data sheet Supplied by Idemitsu Lubricants America Corporation 701 Port Rd. Jeffersonville, IN. 47130 Telephone: 812-285-8234 Fax: 812-285-8243 Contact Name: Robin Hutchens Email: This email address is being protected from spambots. You need JavaScript enabled to view it. 24 Hour Emergency Phone Number Within USA and Canada: 1-800-424-9300 Outside USA and Canada: + 1 703-741-5970 (collect calls accepted) _____________________________________________________________________________________________ Page 1 / 10 Not regulated PPE Revision Date: 05-Jan-2015 Revision Number: 1 Transport Symbol A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges SAFETY DATA SHEET Product Name: 10-4084, 19260643 - ACDelco Air Conditioner Compressor Oil _____________________________________________________________________________________________ _____________________________________________________________________________________________ Page 2 / 10 2.1 Classification This material is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) and WHMIS 2015 Acute toxicity - Oral Not classified Acute toxicity - Dermal Not classified Acute toxicity - Inhalation (Gases) Not classified Acute toxicity - Inhalation (Vapors) Not classified Acute toxicity - Inhalation (Dusts/Mists) Not classified Skin corrosion/irritation Not classified Serious eye damage/eye irritation Not classified Respiratory sensitization Not classified Skin sensitization Not classified Germ cell mutagenicity Not classified Carcinogenicity Not classified Reproductive toxicity Category 2 Specific target organ toxicity (single exposure) Not classified Specific target organ toxicity (repeated exposure) Not classified Aspiration toxicity Not classified 2.2. Label elements Signal word Warning Hazard statements H361 - Suspected of damaging fertility or the unborn child Precautionary Statements - Prevention: P201 - Obtain special instructions before use P202 - Do not handle until all safety precautions have been read and understood P281 - Use personal protective equipment as required Precautionary Statements - Response: P308 + P313 - IF exposed or concerned: Get medical advice/attention Precautionary Statements - Storage: P405 - Store locked up Precautionary Statements - Disposal: P501 - Dispose of contents/ container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable 2.3 Other information Other hazards ? Harmful to aquatic life ? Avoid release to the environment Unknown acute toxicity 96.4% of the mixture consists of ingredient(s) of unknown toxicity Revision Date: 05-Jan-20153440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges 2. HAZARDS IDENTIFICATION GHS Physical Hazard Category Number None _____________________________________________________________________________________________ 3. COMPOSITION/INFORMATION ON INGREDIENTS 3.1 Substances Not applicable 3.2 Mixtures Hazardous Components Chemical Name CAS-No Weight % Notes Tricresylphosphate 1330-78-5 <1 Non-Hazardous Components Chemical Name CAS-No Weight % Polypropylene Glycol - <95 4. FIRST AID MEASURES 4.1 First Aid Measures General Advice If symptoms persist, call a physician. Show this safety data sheet to the doctor in attendance. Eye Contact Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. If symptoms persist, call a physician. Skin Contact Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If skin irritation persists, call a physician. Inhalation Move to fresh air in case of accidental inhalation of vapors. If breathing is difficult, give oxygen. If not breathing, give artificial respiration. Call a physician immediately. Ingestion Do not induce vomiting without medical advice. If vomiting occurs naturally, have casualty lean forward to reduce the risk of aspiration. Swallowing small quantities of diluted product may cause nausea, diarrhea or abdominal distress. Call a physician. Protection of First-aiders Use personal protective equipment. Avoid contact with skin, eyes and clothing. 4.2 Most important symptoms and effects, both acute and delayed Symptoms No information available. 4.3 Indication of any immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Flammable Properties NFPA: Class IIIB Combustible Liquid 5.1 Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment Unsuitable Extinguishing Media No information available. _____________________________________________________________________________________________ Page 3 / 10 3440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges Revision Date: 05-Jan-2015 _____________________________________________________________________________________________ 5.2 Specific Hazards Arising from the Chemical Keep product and empty container away from heat and sources of ignition. Hazardous combustion products: During a fire, smoke may contain the original material in addition to combustion products of varying composition which may be toxic and / or irritating. Combustion products may include and are not limited to, Carbon oxides, Oxides of Phosphorus, aldehydes. 5.3 Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES 6.1 Personal precautions, protective equipment and emergency procedures Personal precautions Avoid contact with the skin and the eyes. Use personal protective equipment. Remove all sources of ignition. Avoid breathing vapors or mists. Ensure adequate ventilation. 6.2 Environmental Precautions Environmental Precautions Prevent further leakage or spillage if safe to do so. Prevent product from entering drains. Do not allow material to contaminate ground water system. Do not flush into surface water or sanitary sewer system. Large Spills: Dike far ahead of liquid spill for later recovery and disposal. Prevent entry into waterways, sewers, basements or confined areas. See section 3 for more information. See section 5 for more information. See section 4 for more information. See section 8 for more information. Avoid contact with spilled material. Warn or evacuate occupants in surrounding and downwind areas if required due to toxicity or flammability of the material. See Section 3 for Significant Hazards. See Section 5 for fire fighting information. See Section 4 for First Aid Advice. See Section 8 for Personal Protective Equipment. 6.3 Methods and material for containment and cleaning up Methods for Clean-up Contain and collect spillage with non-combustible absorbent material, (e.g. sand, earth, diatomaceus earth, vermiculite) and place in container for disposal according to local / national regulations (see section 13). Pick up and transfer to properly labeled containers. Spill Management LARGE SPILLS Eliminate sources of ignition. Prevent additional discharge of material if possible to do so without hazard. For small spills implement cleanup procedures; for large spills implement cleanup procedures and, if in public area, keep public away and advise authorities. Also, if this product is subject to CERCLA reporting (see Section 15 Regulatory Information) notify the National Response Center. WATER SPILLS Prevent liquid entering sewers, watercourses, or low areas. Contain spilled liquid with sand or earth. Recover by pumping or with suitable absorbent. If liquid is too viscous for pumping, scrape up. Consult an expert on disposal of recovered material and ensure conformity to local disposal regulations. 7. HANDLING AND STORAGE 7.1. Precautions for safe handling _____________________________________________________________________________________________ Page 4 / 10 3440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges Revision Date: 05-Jan-2015 _____________________________________________________________________________________________ Handling Wear personal protective equipment. Do not breathe vapors or spray mist. Remove and wash contaminated clothing before re-use. Keep away from open flames, hot surfaces and sources of ignition. Take necessary action to avoid static electricity discharge (which might cause ignition of organic vapors). Safe Handling Advice Handle in accordance with good industrial hygiene and safety practices. 7.2. Conditions for safe storage, including any incompatibilities Storage Keep in properly labeled containers. Keep container tightly closed in a dry and well-ventilated place. Incompatible Materials and/or Coatings No information available 8. EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1 Control parameters Exposure Guidelines This product does not contain any hazardous materials with occupational exposure limits established by the region specific regulatory bodies. 8.2. Exposure controls Appropriate engineering controls Ensure adequate ventilation, especially in confined areas. Consider the potential hazards of this material (see Section 2), applicable exposure limits, job activities, and other substances in the work place when designing engineering controls and selecting personal protective equipment. If engineering controls or work practices are not adequate to prevent exposure to harmful levels of this material, the personal protective equipment listed below is recommended. The user should read and understand all instructions and limitations supplied with the equipment since protection is usually provided for a limited time or under certain circumstances. Personal Protective Equipment Eye/face protection Safety glasses equipped with side shields are recommended as minimum protection in industrial settings. Skin protection Wear impervious protective clothing, including boots, gloves, lab coat, apron or coveralls, as appropriate to prevent skin contact. Glove Type: Nitriles, Neoprene. Respiratory protection If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. Positive-pressure supplied air respirators may be required for high airborne contaminant concentrations. Respiratory protection must be provided in accordance with current local regulations. General Hygiene Considerations Clean equipment, work area and clothing regularly. 9. PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on basic physical and chemical properties Appearance Light Yellow _____________________________________________________________________________________________ Page 5 / 10 Revision Date: 05-Jan-20153440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges _____________________________________________________________________________________________ Physical State Liquid Odor Characteristic Odor Threshold No information available pH Not applicable Melting point / melting range Not applicable Boiling point / boiling range No information available Flash Point > 200 ?C / 392 ?F COC ASTM D92 Evaporation Rate No information available Flammability Limit in Air No information available Explosion Limits No information available Vapor Pressure No information available Vapor Density (Air) No information available Density 0.99 g/cm 3 @15?C Solubility No information available Partition Coefficient (n-octanol/water) No information available Autoignition Temperature No information available Decomposing Temperature No information available Viscosity @ 40C = 48.16 cSt; @ 100C = 10.61 cSt Other Information No additional information available 10. STABILITY AND REACTIVITY 10.1 Reactivity Reactivity The product is chemically stable 10.2 Chemical stability Chemical Stability Stable under recommended storage conditions. 10.3 Possibility of Hazardous Reactions Possibility of Hazardous Reactions None under normal processing. 10.4 Conditions to Avoid Conditions to Avoid Heat, flames and sparks. 10.5 Incompatible Materials Incompatible Materials Strong oxidizing agents. 10.6 Hazardous Decomposition Products Hazardous decomposition products Thermal decomposition can lead to release of irritating gases and vapors. 11. TOXICOLOGICAL INFORMATION 11.1 Information on likely routes of exposure Inhalation May cause irritation of respiratory tract. Eye contact May cause irritation. Skin Contact May cause skin irritation and/or dermatitis. Ingestion May be harmful if swallowed. _____________________________________________________________________________________________ Page 6 / 10 Revision Date: 05-Jan-20153440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges _____________________________________________________________________________________________ Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation Tricresylphosphate 1330-78-5 3000 mg/kg (Rat) 1701 mg/kg (Rabbit) 11.2 Information on toxicological effects Symptoms No information available. 11.3 Delayed and immediate effects as well as chronic effects from short and long-term exposure Skin corrosion/irritation Repeated or prolonged skin contact may cause skin irritation and/or dermatitis and sensitization of susceptible persons. Serious eye damage/eye irritation No information available. Sensitization May cause sensitization of susceptible persons. Mutagenic effects No information available. 11.4 Carcinogenicity Carcinogenicity No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP, IARC, OSHA, or ACGIH. Legend: NTP: (National Toxicity Program), ACGIH: (American Conference of Governmental Industrial Hygienists), IARC: (International Agency for Research on Cancer), OSHA: (Occupational Safety & Health Administration) Reproductive Effects Suspected of damaging fertility or the unborn child. Substances which cause concern for human fertility. STOT - single exposure None known. STOT - repeated exposure This product is not expected to produce neurotoxic effects under normal conditions of use and with appropriate personal hygiene practices. This product contains tricresyl phosphate (TCP). Overexposure to TCP by swallowing, prolonged or repeated breathing of oil mist, or prolonged or repeated skin contact may produce nervous system disorders including gastrointestinal disturbances, numbness, muscular cramps, weakness and paralysis. Chronic Toxicity Prolonged or repeated exposure increases the risk. Aspiration hazard No information available. 11.5 Acute Toxicity Unknown acute toxicity 96.4% of the mixture consists of ingredient(s) of unknown toxicity 12. ECOLOGICAL INFORMATION 12.1 Ecotoxicity Ecotoxicity effects Harmful to aquatic organisms Unknown aquatic toxicity 97.3% of the mixture consists of components(s) of unknown hazards to the aquatic environment _____________________________________________________________________________________________ Page 7 / 10 3440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges Revision Date: 05-Jan-2015 _____________________________________________________________________________________________ 12.2 Persistence and degradability No information available. 12.3 Bioaccumulation/Accumulation No information available 12.4. Mobility in soil No information available PBT and vPvB assessment No information available 12.5 Other adverse effects: No information available 13. DISPOSAL CONSIDERATIONS Hazard characteristic and regulatory waste stream classification can change with product use. Accordingly, it is the responsibility of the user to determine the proper storage, transportation, treatment and/or disposal methodologies for spent materials and residues at the time of disposition.To minimize exposure, see Section 8 (Exposure Controls/Personal Protection) of the SDS. Waste Disposal Method This material, as supplied, is not a hazardous waste according to Federal regulations (40 CFR 261). This material could become a hazardous waste if it is mixed with or otherwise comes in contact with a hazardous waste, if chemical additions are made to this material, or if the material is processed or otherwise altered. Consult 40 CFR 261 to determine whether the altered material is a hazardous waste. Consult the appropriate state, regional, or local regulations for additional requirements. Contaminated packaging Dispose of in accordance with local regulations. 14. TRANSPORT INFORMATION DOT Not regulated IATA Not regulated IMDG/IMO Not regulated 15. REGULATORY INFORMATION International Inventories TSCA All ingredients are on the inventory or exempt from listing DSL Not all ingredients are listed on the DSL Inventory List NDSL There are ingredients listed on the NDSL Inventory List Chemical Name NDSL CAS-No Weight % Polypropylene Glycol X Confidential >90 Oxirane Compound X Confidential 1-2 Tetradecane compound X Confidential 1-2 EINECS All ingredients are on the inventory or exempt from listing ELINCS Not Listed ENCS All ingredients are on the inventory or exempt from listing CHINA All ingredients are on the inventory or exempt from listing KECL All ingredients are on the inventory or exempt from listing _____________________________________________________________________________________________ Page 8 / 10 3440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges Revision Date: 05-Jan-2015 _____________________________________________________________________________________________ PICCS All ingredients are on the inventory or exempt from listing AICS Does not comply NZloC Does not comply Mexico (INSQ) Does not comply USA Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 SARA 311/312 Hazardous Categorization Acute Health Hazard No Chronic Health Hazard Yes Fire Hazard No Sudden Release of Pressure Hazard No Reactive Hazard No CERCLA/SARA 302 & 304 Section 302 & 304 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 355. Clean Air Act, Section 112 Hazardous Air Pollutants (HAPs) (see 40 CFR 61) This product does not contain any HAPs. State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals State Right-to-Know This product does not contain any substances regulated by state right-to-know regulations New Jersey Worker and Community Right-to-Know Act: Contact Idemitsu Lubricants America for this information Canada This material has been classified in accordance with the WHMIS 2015 regulation Chemical Name CAS-No Weight % NPRI B-Pinene 127-91-3 <1 Listed BHT Confidential <1 Listed Legend NPRI - National Pollutant Release Inventory 16. OTHER INFORMATION _____________________________________________________________________________________________ Page 9 / 10 3440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges Revision Date: 05-Jan-2015 _____________________________________________________________________________________________ Prepared By Susie Bibb Revision Date: 05-Jan-2015 Revision Summary: Formulation Change Disclaimer: The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Safety Data Sheet _____________________________________________________________________________________________ Page 10 / 10 3440025-062 - A/C Delco PS-D1 GM#19260643, 6 x 8oz Cartridges NFPA Health: 1 Revision Date: 05-Jan-2015 Flammability: 1 Instability 0