3m 03576 MATERIAL SAFETY 3M DATA SHEET 3M Center St. Paul, Minnesota 55144-1000 1-800-364-3577 or (651) 737-6501 (24 hours) Copyright, 2000, Minnesota Mining and Manufacturing Company . All rights reserved. Copying and/or downloading of this information for the purpose of properly utilizing 3M produc ts is allowed provided that: 1) the information is copied in full with no changes unless prior agreement is obtained from 3M, and 2) neither the copy nor the original is resold or otherwise distributed with the intention of earning a profit there on. DIVISION: CONSTRUCTION AND HOME IMPROVEMENT PRODS TRADE NAME: Scotchgard(TM) Auto-Pak(TM) Automotive Upholstery & Carpet Clean er Cat. 3576 ID NUMBER/U.P.C.: 70-0705-5051-5 00-51131-03576-8 70-0705-8088-4 00-51131-03576 -8 70-0707-1937-5 00-51131-03576-8 70-0707-2792-3 00-51131-03576 -8 ISSUED: June 08, 2000 SUPERSEDES: March 09, 2000 DOCUMENT: 10-2518-8 ------------------------------------------------------------------ ----------- 1. INGREDIENT C.A.S. NO. PERC ENT ------------------------------------------------------------------ ----------- WATER................................... 7732-18-5 75 - 85 ISOBUTANE PROPELLANT.................... 75-28-5 5 - 10 Page 1 3m 03576 SODIUM LAURYL SULFATE................... 151-21-3 1 - 5 LAURYLDIMETHYLAMINE OXIDE............... 1643-20-5 1 - 5 2-BUTOXYETHANOL......................... 111-76-2 1 - 5 FLUOROCHEMICAL.......................... TradeSecret 1 - 5 ORGANIC ACID ESTER SALT................. 25882-44-4 1 - 5 This product contains the following toxic chemical or chemicals su bject to the reporting requirements of Section 313 of Title III of the Emer gency Planning and Community Right-To-Know Act of 1986 and 40 CFR Part 3 72: 2-BUTOXYETHANOL ------------------------------------------------------------------ ----------- 2. PHYSICAL DATA ------------------------------------------------------------------ ----------- BOILING POINT:................. ca. 212.00 F VAPOR PRESSURE:................ N/A VAPOR DENSITY:................. N/A EVAPORATION RATE:.............. N/A SOLUBILITY IN WATER:........... apprec. SPECIFIC GRAVITY:.............. ca. 0.940 Water=1 PERCENT VOLATILE:.............. ca. 94.00 % by wt pH:............................ ca. 9.20 VISCOSITY:..................... N/D MELTING POINT:................. N/D ------------------------------------------------------------------ ----------- Abbreviations: N/D - Not Determined N/A - Not Applicable CA - Ap proximately MSDS: Scotchgard(TM) Auto-Pak(TM) Automotive Upholstery & Carpet C leaner Cat. 3576 June 08, 2000 PAGE 2 Page 2 3m 03576 ------------------------------------------------------------------ ----------- 2. PHYSICAL DATA (continued) ------------------------------------------------------------------ ----------- APPEARANCE AND ODOR: Liquid in aerosol container, white foam, slight odor of ammonia ------------------------------------------------------------------ ----------- 3. FIRE AND EXPLOSION HAZARD DATA ------------------------------------------------------------------ ----------- FLASH POINT:................... N/A FLAMMABLE LIMITS - LEL:........ N/D FLAMMABLE LIMITS - UEL:........ N/D AUTOIGNITION TEMPERATURE:...... N/D EXTINGUISHING MEDIA: Water spray, Carbon dioxide, Dry chemical, Foam SPECIAL FIRE FIGHTING PROCEDURES: Not applicable UNUSUAL FIRE AND EXPLOSION HAZARDS: Closed containers exposed to heat from fire may build pressure a nd explode. NFPA HAZARD CODES: HEALTH: 1 FIRE: 1 REACTIVITY: 1 UNUSUAL REACTION HAZARD: none Page 3 3m 03576 ------------------------------------------------------------------ ----------- 4. REACTIVITY DATA ------------------------------------------------------------------ ----------- STABILITY: Stable INCOMPATIBILITY - MATERIALS/CONDITIONS TO AVOID: Heat. HAZARDOUS POLYMERIZATION: Hazardous polymerization will not occur. HAZARDOUS DECOMPOSITION PRODUCTS: Carbon Monoxide and Carbon Dioxide. ------------------------------------------------------------------ ----------- 5. ENVIRONMENTAL INFORMATION ------------------------------------------------------------------ ----------- SPILL RESPONSE: Refer to other sections of this MSDS for information regarding physical and health hazards, respiratory protection, ventilation , and personal protective equipment. Extinguish all ignition sources. ------------------------------------------------------------------ ----------- Abbreviations: N/D - Not Determined N/A - Not Applicable CA - Ap proximately MSDS: Scotchgard(TM) Auto-Pak(TM) Automotive Upholstery & Carpet C leaner Cat. 3576 June 08, 2000 PAGE 3 ------------------------------------------------------------------ ----------- 5. ENVIRONMENTAL INFORMATION (continued) Page 4 3m 03576 ------------------------------------------------------------------ ----------- Cover with absorbent material. Clean up residue. Place in a U. S. DOT-approved container. RECOMMENDED DISPOSAL: Incinerate in a permitted hazardous waste incinerator. Do not puncture or burn cans in a household incinerator. Facility must be capable of handling aerosol cans. Dispose of empty cans in a sanitary landfill. Dispose of completely absorbed waste product in a facility permitted to accept chemical wastes. ENVIRONMENTAL DATA: No data available. REGULATORY INFORMATION: Volatile Organic Compounds: ca. 362 gms/liter South Coast Air Qu ality Mgmt Dist Method ca. 9.5% (calc. per CARB). VOC Less H2O & Exempt Solvents: N/D. Since regulations vary, consult applicable regulations or author ities before disposal. U.S. EPA Hazardous Waste Number = D001 (Ignit able) EPCRA HAZARD CLASS: FIRE HAZARD: No PRESSURE: Yes REACTIVITY: No ACUTE: Yes CHRON IC: Yes ------------------------------------------------------------------ ----------- 6. SUGGESTED FIRST AID ------------------------------------------------------------------ ----------- Page 5 3m 03576 EYE CONTACT: Immediately flush eyes with large amounts of water. Get immediat e medical attention. SKIN CONTACT: Wash affected area with soap and water. INHALATION: If signs/symptoms occur, remove person to fresh air. If signs/symptoms continue, call a physician. IF SWALLOWED: Do not induce vomiting. Drink two glasses of water. Call a physi cian. ------------------------------------------------------------------ ----------- Abbreviations: N/D - Not Determined N/A - Not Applicable CA - Ap proximately MSDS: Scotchgard(TM) Auto-Pak(TM) Automotive Upholstery & Carpet C leaner Cat. 3576 June 08, 2000 PAGE 4 ------------------------------------------------------------------ ----------- Page 6 3m 03576 7. PRECAUTIONARY INFORMATION ------------------------------------------------------------------ ----------- EYE PROTECTION: Avoid eye contact with vapor, spray, or mist. Do not spray in eyes, in mouth or on skin. SKIN PROTECTION: Avoid skin contact. Keep children and pets out of the vehicle until product has thoroughly dried. RECOMMENDED VENTILATION: Do not use in a confined area or areas with little or no air movement. Use in a well-ventilated area. Use with adequate dil ution ventilation. Use only as directed and only in areas adequately ventilated to remove vapors and prevent vapor buildup. Maintain cross ventilat ion until sprayed article is dry through the use of fans, and open windows and doors. RESPIRATORY PROTECTION: Avoid breathing of vapors, mists or spray. Avoid breathing of airborne material. PREVENTION OF ACCIDENTAL INGESTION: Do not eat, drink or smoke when using this product. Wash exposed areas thoroughly with soap and water. Wash hands after handling and before eating. RECOMMENDED STORAGE: Store away from areas where product may come into contact with f Page 7 3m 03576 ood or pharmaceuticals. Store at temperatures below 120 degrees F ( 49 degrees C). Store at temperatures above 32 degrees F (O degrees C). Keep out of the reach of children. FIRE AND EXPLOSION AVOIDANCE: Aerosol container contains flammable gas under pressure. Do not pierce or burn container, even after use. OTHER PRECAUTIONARY INFORMATION: Keep small children and pets out of the vehicle while applying product and until carpet and upholstery is thoroughly dry. ------------------------------------------------------------------ ----------- Abbreviations: N/D - Not Determined N/A - Not Applicable CA - Ap proximately MSDS: Scotchgard(TM) Auto-Pak(TM) Automotive Upholstery & Carpet C leaner Cat. 3576 June 08, 2000 PAGE 5 ------------------------------------------------------------------ ----------- 7. PRECAUTIONARY INFORMATION (continued) ------------------------------------------------------------------ ----------- EXPOSURE LIMITS Page 8 3m 03576 INGREDIENT VALUE UNIT TYPE AUTH SKIN* ------------------------------------------------------------------ ----------- WATER................................ NONE NONE NONE NONE ISOBUTANE PROPELLANT................. NONE NONE NONE NONE SODIUM LAURYL SULFATE................ NONE NONE NONE NONE LAURYLDIMETHYLAMINE OXIDE............ NONE NONE NONE NONE 2-BUTOXYETHANOL...................... 25 PPM TWA ACGIH Y 2-BUTOXYETHANOL...................... 25 PPM TWA OSHAV Y OSHA VACATED PEL 2-BUTOXYETHANOL...................... 50 PPM TWA OSHA Y FLUOROCHEMICAL....................... NONE NONE NONE NONE ORGANIC ACID ESTER SALT.............. NONE NONE NONE NONE * SKIN NOTATION: Listed substances indicated with 'Y' under SKIN refer to the potential contribution to the overall exposure by the cutaneou s route including mucous membrane and eye, either by airborne or, more par ticularly, by direct contact with the substance. Vehicles can alter skin abs orption. SOURCE OF EXPOSURE LIMIT DATA: - ACGIH: American Conference of Governmental Industrial Hygienists - OSHA: Occupational Safety and Health Administration - OSHAV: Occupational Safety and Health Administration Vacated PEL . Vacated Permissible Exposure Limits (PEL) are enforced as the OSHA PEL in some states. Check with your local regulatory authority. - NONE: None Established Page 9 3m 03576 ------------------------------------------------------------------ ----------- 8. HEALTH HAZARD DATA ------------------------------------------------------------------ ----------- EYE CONTACT: Mild Eye Irritation: signs/symptoms can include redness, swellin g, pain, and tearing. SKIN CONTACT: Mild Skin Irritation (after prolonged or repeated contact): signs/symptoms can include redness, swelling, and itching. May be absorbed through the skin and produce effects similiar to those caused by inhalation and/or ingestion. INHALATION: Irritation (upper respiratory): signs/symptoms can include soren ess of the nose and throat, coughing and sneezing. ------------------------------------------------------------------ ----------- Abbreviations: N/D - Not Determined N/A - Not Applicable CA - Ap proximately MSDS: Scotchgard(TM) Auto-Pak(TM) Automotive Upholstery & Carpet C leaner Cat. 3576 June 08, 2000 PAGE 6 ------------------------------------------------------------------ ----------- 8. HEALTH HAZARD DATA (continued) ------------------------------------------------------------------ ----------- Page 10 3m 03576 IF SWALLOWED: Ingestion is not a likely route of exposure to this product. WHILE THE FOLLOWING EFFECTS ARE ASSOCIATED WITH ONE OR MORE OF T HE INDIVIDUAL INGREDIENTS IN THIS PRODUCT AND ARE REQUIRED TO BE INCLUDED ON THE MSDS BY THE U.S. OSHA HAZARD COMMUNICATION STAND ARD, THEY ARE NOT EXPECTED EFFECTS DURING FORESEEABLE USE OF THIS PRO DUCT. Irritation of Gastrointestinal Tissues: signs/symptoms can inclu de pain, vomiting, abdominal tenderness, nausea, blood in vomitus, and blood in feces. ------------------------------------------------------------------ ----------- SECTION CHANGE DATES ------------------------------------------------------------------ ----------- HEADING SECTION CHANGED SINCE March 09, 2000 ISSUE Page 11 3m 03576 ------------------------------------------------------------------ ----------- Abbreviations: N/D - Not Determined N/A - Not Applicable CA - Ap proximately ------------------------------------------------------------------ ----------- The information in this Material Safety Data Sheet (MSDS) is belie ved to be correct as of the date issued. 3M MAKES NO WARRANTIES, EXPRESS ED OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR COURSE OF PERFORMANCE OR USAGE OF TRADE. User is responsible for determinin g whether the 3M product is fit for a particular purpose and suitabl e for user's method of use or application. Given the variety of factors that can affect the use and application of a 3M product, some of which are uniquely within the user's knowledge and control, it is essential that the user evaluate the 3M product to determine whether it is fit fo r a particular purpose and suitable for user's method of use or applic ation. 3M provides information in electronic form as a service to its cus tomers. Due to the remote possibility that electronic transfer may have re sulted in errors, omissions or alterations in this information, 3M makes no representations as to its completeness or accuracy. In addition, information obtained from a database may not be as current as the information in the MSDS available directly from 3M. Page 12