SAFETY DATA SHEET Revision Date 13-Jul-2018 Version 5 1. IDENTIFICATION Product identifier Product Name PENETRATING GRADE THREADLOCKER GREEN 6ML Other means of identification Product Code 29000 Recommended use of the chemical and restrictions on use Recommended Use Adhesive Uses advised against No information available Details of the supplier of the safety data sheet 24-hour emergency phone number Chem-Tel: 800-255-3924 International Emergency: 00+1+ 813-248-0585 Contract Number: MIS0003453 E-mail address: This email address is being protected from spambots. You need JavaScript enabled to view it. 2. HAZARDS IDENTIFICATION Classification OSHA Regulatory Status This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) Skin corrosion/irritation Category 2 Serious eye damage/eye irritation Category 2A Carcinogenicity Category 2 Specific target organ toxicity (single exposure) Category 3 Label elements Emergency Overview Manufacturer Address ITW Permatex 6875 Parkland Blvd. Solon, OH 44139 USA May Also Be Distributed by: ITW Permatex Canada 101-2360 Bristol Circle Oakville, ON Canada L6H 6M5 Telephone: (800) 924-6994 Signal word Warning Causes skin irritation Causes serious eye irritation Suspected of causing cancer May cause respiratory irritation _____________________________________________________________________________________________ Page 1 / 8 English chemical name _____________________________________________________________________________________________ 29000 - PENETRATING GRADE THREADLOCKER GREEN 6ML Revision Date 13-Jul-2018 Precautionary Statements - Prevention Obtain special instructions before use Do not handle until all safety precautions have been read and understood Use personal protective equipment as required Avoid breathing dust/fume/gas/mist/vapors/spray Use only outdoors or in a well-ventilated area Wash face, hands and any exposed skin thoroughly after handling Precautionary Statements - Response IF exposed or concerned: Get medical advice/attention IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention IF ON SKIN: Wash with plenty of soap and water If skin irritation occurs: Get medical advice/attention Take off contaminated clothing and wash before reuse IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing Precautionary Statements - Storage Store locked up Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable Other Information - Not applicable 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance(s) Chemical Name CAS No Weight-% DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 1 - 5 CUMENE 98-82-8 0.1 - 1 4. FIRST AID MEASURES Description of first aid measures General advice Get medical advice/attention if you feel unwell. Eye contact IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Appearance Green Physical state Liquid Odor Mild _____________________________________________________________________________________________ Page 2 / 8 English chemical name _____________________________________________________________________________________________ 29000 - PENETRATING GRADE THREADLOCKER GREEN 6ML Revision Date 13-Jul-2018 Skin contact IF ON SKIN:. Wash skin with soap and water. If skin irritation persists, call a physician. Take off contaminated clothing and wash before reuse. Inhalation IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. If symptoms persist, call a physician. Ingestion IF SWALLOWED:. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician. Self-protection of the first aider Use personal protective equipment as required. Most important symptoms and effects, both acute and delayed Symptoms See section 2 for more information. Indication of any immediate medical attention and special treatment needed Note to physicians Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Carbon dioxide (CO2), Dry chemical, Foam Unsuitable extinguishing media None Specific hazards arising from the chemical None in particular. Explosion data Sensitivity to Mechanical Impact None. Sensitivity to Static Discharge None. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Ensure adequate ventilation, especially in confined areas. Avoid contact with eyes and skin. Use personal protective equipment as required. Environmental precautions Environmental precautions See Section 12 for additional Ecological Information. Methods and material for containment and cleaning up Methods for containment Prevent further leakage or spillage if safe to do so. Methods for cleaning up Ensure adequate ventilation. Soak up with inert absorbent material. Sweep up and shovel into suitable containers for disposal. Prevention of secondary hazards Clean contaminated objects and areas thoroughly observing environmental regulations. _____________________________________________________________________________________________ Page 3 / 8 English chemical name 7. HANDLING AND STORAGE _____________________________________________________________________________________________ 29000 - PENETRATING GRADE THREADLOCKER GREEN 6ML Revision Date 13-Jul-2018 Precautions for safe handling Advice on safe handling Handle in accordance with good industrial hygiene and safety practice. Avoid breathing vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling. Wash contaminated clothing before reuse. Use personal protective equipment as required. Conditions for safe storage, including any incompatibilities Storage Conditions Keep containers tightly closed in a cool, well-ventilated place. Store locked up. Incompatible materials Strong oxidizing agents 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Exposure Guidelines . Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH CUMENE 98-82-8 TWA: 50 ppm TWA: 50 ppm TWA: 245 mg/m3 (vacated) TWA: 50 ppm (vacated) TWA: 245 mg/m3 (vacated) S* S* IDLH: 900 ppm TWA: 50 ppm TWA: 245 mg/m3 NIOSH IDLH Immediately Dangerous to Life or Health Other Information Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Controls Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/face protection Tight sealing safety goggles. Skin and body protection Wear protective natural rubber, nitrile rubber, Neoprene? or PVC gloves. Respiratory protection Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as appropriate. General Hygiene Considerations When using do not eat, drink or smoke. Regular cleaning of equipment, work area and clothing is recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Physical state Liquid Appearance Green Odor Mild Odor threshold No information available Property Values Remarks ? Method pH No information available Melting point / freezing point No information available Boiling point / boiling range > 200 ?C / >392 ?F _____________________________________________________________________________________________ Page 4 / 8 English chemical name _____________________________________________________________________________________________ 29000 - PENETRATING GRADE THREADLOCKER GREEN 6ML Revision Date 13-Jul-2018 Explosive properties No information available Oxidizing properties No information available Other Information Softening point No information available Molecular weight No information available VOC Content (%) 0.76% (7.7 g/l) Density No information available Bulk density No information available 10. STABILITY AND REACTIVITY Reactivity Chemical stability Stable under recommended storage conditions Possibility of Hazardous Reactions None under normal processing. Conditions to avoid Excessive heat. Incompatible materials Strong oxidizing agents Hazardous Decomposition Products Carbon oxides Aldehydes 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure Inhalation May cause irritation of respiratory tract. Eye contact Contact with eyes may cause irritation. May cause redness and tearing of the eyes. Skin contact May cause skin irritation and/or dermatitis. Ingestion Ingestion may cause irritation to mucous membranes. Flash point 131 ?C / 268 ?F Evaporation rate No information available Flammability (solid, gas) No information available Flammability Limit in Air Upper flammability limit: No information available Lower flammability limit: No information available Vapor pressure No information available Vapor density No information available Air = 1 Relative density 1.02 Water solubility Immiscible in water Solubility in other solvents No information available Partition coefficient No information available Autoignition temperature No information available Decomposition temperature No information available Kinematic viscosity No information available Dynamic viscosity 40 mPas @20?C (68?F) Stable under normal conditions _____________________________________________________________________________________________ Page 5 / 8 English chemical name _____________________________________________________________________________________________ 29000 - PENETRATING GRADE THREADLOCKER GREEN 6ML Revision Date 13-Jul-2018 Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 = 382 mg/kg ( Rat ) = 0.126 mL/kg ( Rabbit ) = 220 ppm ( Rat ) 4 h CUMENE 98-82-8 = 1400 mg/kg ( Rat ) = 12300 ?L/kg ( Rabbit ) > 3577 ppm ( Rat ) 6 h = 39000 mg/m3 ( Rat ) 4 h Information on toxicological effects Symptoms No information available. Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization No information available. Germ cell mutagenicity No information available. Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Chemical Name ACGIH IARC NTP OSHA CUMENE 98-82-8 - Group 2B Reasonably Anticipated X IARC (International Agency for Research on Cancer) Not classifiable as a human carcinogen Group 2B - Possibly Carcinogenic to Humans NTP (National Toxicology Program) Reasonably Anticipated - Reasonably Anticipated to be a Human Carcinogen OSHA (Occupational Safety and Health Administration of the US Department of Labor) X - Present The following values are calculated based on chapter 3.1 of the GHS document . ATEmix (oral) 10914 mg/kg ATEmix (dermal) 31429 mg/kg ATEmix (inhalation-dust/mist) 14.3 mg/l 12. ECOLOGICAL INFORMATION Ecotoxicity 0.305 % of the mixture consists of component(s) of unknown hazards to the aquatic environment Persistence and degradability No information available. Bioaccumulation No information available. Mobility No information available. Chemical Name Partition coefficient CUMENE 98-82-8 3.7 Other adverse effects No information available 13. DISPOSAL CONSIDERATIONS Waste treatment methods Disposal of wastes Disposal should be in accordance with applicable regional, national and local laws and regulations. _____________________________________________________________________________________________ Page 6 / 8 English chemical name _____________________________________________________________________________________________ 29000 - PENETRATING GRADE THREADLOCKER GREEN 6ML Revision Date 13-Jul-2018 Contaminated packaging Do not reuse container. US EPA Waste Number Not applicable This product contains one or more substances that are listed with the State of California as a hazardous waste. Chemical Name California Hazardous Waste Status DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 Toxic Ignitable CUMENE 98-82-8 Toxic Ignitable 14. TRANSPORT INFORMATION DOT Proper shipping name: Not regulated IATA Proper shipping name: Not regulated IMDG Proper shipping name: Not regulated 15. REGULATORY INFORMATION International Inventories TSCA Complies DSL/NDSL Complies EINECS/ELINCS Complies ENCS Complies IECSC Complies KECL Complies PICCS Complies AICS Complies Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 Chemical Name SARA 313 - Threshold Values % DIMETHYLBENZYL HYDROPEROXIDE - 80-15-9 1.0 SACCHARIN - 81-07-2 1.0 SARA 311/312 Hazard Categories Acute health hazard Yes Chronic Health Hazard No _____________________________________________________________________________________________ Page 7 / 8 English chemical name _____________________________________________________________________________________________ 29000 - PENETRATING GRADE THREADLOCKER GREEN 6ML Revision Date 13-Jul-2018 Fire hazard No Sudden release of pressure hazard No Reactive Hazard No CWA (Clean Water Act) This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42) CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ) DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 10 lb - RQ 10 lb final RQ RQ 4.54 kg final RQ CUMENE 98-82-8 5000 lb - RQ 5000 lb final RQ RQ 2270 kg final RQ US State Regulations California Proposition 65 This product contains the following Proposition 65 chemicals Chemical Name California Proposition 65 CUMENE - 98-82-8 Carcinogen U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 X X X SACCHARIN 81-07-2 X X X CUMENE 98-82-8 X X X U.S. EPA Label Information EPA Pesticide Registration Number Not applicable WHMIS Hazard Class D2B - Toxic materials 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION OF THE LAST REVISION NFPA (National Fire Protection Association) HMIS (Hazardous Material Information System) Revision Date 13-Jul-2018 Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet NFPA Health hazards 2 Flammability 1 Instability 0 - HMIS Health hazards 2 Flammability 1 Physical hazards 0 Personal protection B _____________________________________________________________________________________________ Page 8 / 8 English chemical name