SAFETY DATA SHEET Revision Date 07-Mar-2017 Version 3 1. IDENTIFICATION Product identifier Product Name PENETRATING GRADE THREADLOCKER GREEN 36ML Other means of identification Product Code 29040 Synonyms None Recommended use of the chemical and restrictions on use Recommended Use Adhesive Uses advised against No information available Details of the supplier of the safety data sheet 24 Hour Emergency Phone Number Chem-Tel: 800-255-3924 International Emergency: 00+1+ 813-248-0585 Contract Number: MIS0003453 E-mail address This email address is being protected from spambots. You need JavaScript enabled to view it. 2. HAZARDS IDENTIFICATION Classification OSHA Regulatory Status This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) Skin corrosion/irritation Category 2 Serious eye damage/eye irritation Category 2A Specific target organ toxicity (repeated exposure) Category 2 Label elements Emergency Overview Manufacturer Address ITW Permatex 6875 Parkland Blvd. Solon, OH 44139 USA May Also Be Distributed by: ITW Permatex Canada 35 Brownridge Road, Unit 1 Halton Hills, ON Canada L7G 0C6 Telephone: (800) 924-6994 Warning Causes skin irritation Causes serious eye irritation May cause damage to organs through prolonged or repeated exposure _____________________________________________________________________________________________ Page 1 / 8 _____________________________________________________________________________________________ 29040 - PENETRATING GRADE THREADLOCKER GREEN 36ML Revision Date 07-Mar-2017 Precautionary Statements - Prevention Do not breathe mist/vapors/spray. Wear suitable gloves and eye/face protection Wash face, hands and any exposed skin thoroughly after handling Precautionary Statements - Response Get medical advice/attention if you feel unwell Specific treatment (see supplemental first aid instructions on this label) IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing Immediately call a POISON CENTER or doctor/physician IF ON SKIN: Wash with plenty of soap and water If skin irritation occurs: Get medical advice/attention Take off contaminated clothing and wash before reuse Precautionary Statements - Storage Store in a well-ventilated place. Keep container tightly closed Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable Other Information - Not applicable 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance(s) Chemical Name CAS No Weight-% Trade Secret DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 1 - 5 * 4. FIRST AID MEASURES Description of first aid measures General advice Get medical advice/attention if you feel unwell. Eye contact IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Skin contact IF ON SKIN:. Wash skin with soap and water. If skin irritation persists, call a physician. Wash contaminated clothing before reuse. Inhalation IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for Appearance Green Physical state Liquid _____________________________________________________________________________________________ Page 2 / 8 Odor Mild _____________________________________________________________________________________________ 29040 - PENETRATING GRADE THREADLOCKER GREEN 36ML Revision Date 07-Mar-2017 breathing. If symptoms persist, call a physician. Ingestion IF SWALLOWED:. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician. Self-protection of the first aider Use personal protective equipment as required. Most important symptoms and effects, both acute and delayed Symptoms See section 2 for more information. Indication of any immediate medical attention and special treatment needed Note to physicians Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Carbon dioxide (CO2), Dry chemical, Foam Unsuitable extinguishing media None. Specific hazards arising from the chemical None in particular. Explosion data Sensitivity to Mechanical Impact None. Sensitivity to Static Discharge None. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Ensure adequate ventilation, especially in confined areas. Avoid contact with eyes and skin. Use personal protective equipment as required. Environmental precautions Environmental precautions Do not flush into surface water or sanitary sewer system. See Section 12 for additional ecological Information. Methods and material for containment and cleaning up Methods for containment Prevent further leakage or spillage if safe to do so. Methods for cleaning up Ensure adequate ventilation. Soak up with inert absorbent material. Sweep up and shovel into suitable containers for disposal. Prevention of secondary hazards Clean contaminated objects and areas thoroughly observing environmental regulations. 7. HANDLING AND STORAGE Precautions for safe handling Advice on safe handling Handle in accordance with good industrial hygiene and safety practice. Avoid breathing vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling. _____________________________________________________________________________________________ Page 3 / 8 _____________________________________________________________________________________________ 29040 - PENETRATING GRADE THREADLOCKER GREEN 36ML Revision Date 07-Mar-2017 Wash contaminated clothing before reuse. Use personal protective equipment as required. Conditions for safe storage, including any incompatibilities Storage Conditions Keep containers tightly closed in a dry, cool and well-ventilated place. Incompatible materials Strong oxidizing agents 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Appropriate engineering controls Engineering Controls Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/face protection Tight sealing safety goggles. Skin and body protection Wear protective natural rubber, nitrile rubber, Neoprene? or PVC gloves. Respiratory protection Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as appropriate. General Hygiene Considerations When using do not eat, drink or smoke. Regular cleaning of equipment, work area and clothing is recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Physical state Liquid Appearance Green Odor Mild Odor threshold No information available Explosive properties No information available Oxidizing properties No information available Property Values Remarks ? Method pH No information available Melting point / freezing point No information available Boiling point / boiling range 200 ?C / 392 ?F Flash point 131 ?C / 268 ?F Evaporation rate No information available Flammability (solid, gas) No information available Flammability Limit in Air Upper flammability limit: No information available Lower flammability limit: No information available Vapor pressure <5 mmHg Vapor density >1 Air = 1 Relative density 1.02 Water solubility Negligible Solubility in other solvents No information available Partition coefficient No information available Autoignition temperature No information available Decomposition temperature No information available Kinematic viscosity No information available Dynamic viscosity 40 mPas @20?C _____________________________________________________________________________________________ Page 4 / 8 _____________________________________________________________________________________________ 29040 - PENETRATING GRADE THREADLOCKER GREEN 36ML Revision Date 07-Mar-2017 Other Information Softening point No information available Molecular weight No information available VOC Content (%) <2% Density No information available Bulk density No information available 10. STABILITY AND REACTIVITY Reactivity Chemical stability Stable under recommended storage conditions Possibility of Hazardous Reactions None under normal processing. Conditions to avoid Excessive heat. Incompatible materials Strong oxidizing agents Hazardous Decomposition Products Carbon oxides Aldehydes 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure Inhalation May cause damage to organs through prolonged or repeated exposure if inhaled. Eye contact Contact with eyes may cause irritation. May cause redness and tearing of the eyes. Skin contact May cause skin irritation and/or dermatitis. Ingestion Ingestion may cause irritation to mucous membranes. Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 = 382 mg/kg ( Rat ) = 0.126 mL/kg ( Rabbit ) = 220 ppm ( Rat ) 4 h Information on toxicological effects Symptoms No information available. Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization No information available. Germ cell mutagenicity No information available. Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. IARC (International Agency for Research on Cancer) Not classifiable as a human carcinogen The following values are calculated based on chapter 3.1 of the GHS document . ATEmix (oral) 10914 mg/kg ATEmix (dermal) 31429 mg/kg No data available _____________________________________________________________________________________________ Page 5 / 8 _____________________________________________________________________________________________ 29040 - PENETRATING GRADE THREADLOCKER GREEN 36ML Revision Date 07-Mar-2017 ATEmix (inhalation-dust/mist) 14.3 mg/l 12. ECOLOGICAL INFORMATION Ecotoxicity 0.351 % of the mixture consists of components(s) of unknown hazards to the aquatic environment Persistence and degradability No information available. Bioaccumulation No information available. Mobility No information available. Other adverse effects No information available 13. DISPOSAL CONSIDERATIONS Waste treatment methods Disposal of wastes Disposal should be in accordance with applicable regional, national and local laws and regulations. Contaminated packaging Do not reuse container. US EPA Waste Number Not applicable This product contains one or more substances that are listed with the State of California as a hazardous waste. Chemical Name California Hazardous Waste Status DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 Toxic Ignitable 14. TRANSPORT INFORMATION DOT Proper shipping name: Not regulated IATA Proper shipping name: Not regulated IMDG Proper shipping name: Not regulated 15. REGULATORY INFORMATION International Inventories TSCA Complies DSL/NDSL Complies EINECS/ELINCS Complies ENCS Complies IECSC Complies _____________________________________________________________________________________________ Page 6 / 8 _____________________________________________________________________________________________ 29040 - PENETRATING GRADE THREADLOCKER GREEN 36ML Revision Date 07-Mar-2017 KECL Complies PICCS Complies AICS Complies Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 Chemical Name SARA 313 - Threshold Values % DIMETHYLBENZYL HYDROPEROXIDE - 80-15-9 1.0 SACCHARIN - 81-07-2 1.0 SARA 311/312 Hazard Categories Acute health hazard Yes Chronic Health Hazard No Fire hazard No Sudden release of pressure hazard No Reactive Hazard No CWA (Clean Water Act) This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42) CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ) DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 10 lb - RQ 10 lb final RQ RQ 4.54 kg final RQ US State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania DIMETHYLBENZYL HYDROPEROXIDE 80-15-9 X X X SACCHARIN 81-07-2 X X X PROPYLENE GLYCOL 57-55-6 X - X U.S. EPA Label Information EPA Pesticide Registration Number Not applicable WHMIS Hazard Class D2B - Toxic materials _____________________________________________________________________________________________ Page 7 / 8 _____________________________________________________________________________________________ 29040 - PENETRATING GRADE THREADLOCKER GREEN 36ML Revision Date 07-Mar-2017 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION OF THE LAST REVISION NFPA (National Fire Protection Association) HMIS (Hazardous Material Information System) Revision Date 07-Mar-2017 Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet NFPA Health hazards 2 Flammability 1 Instability 0 - HMIS Health hazards 2 Flammability 1 Physical hazards 0 Personal protection B _____________________________________________________________________________________________ Page 8 / 8