01/05/2016 EN (English) Page 1 Chain and Cable Lubricant Safety Data Sheet according to the Hazard Communication Standard (CFR29 1910.1200) HazCom2012 Date of issue: 01/05/2016 Revision date: 01/05/2016 Version: 1.0 SECTION 1: Identification of the substance/mixture and of the company/undertaking Product name : Chain and Cable Lubricant Product code : 16-CCL Use of the substance/mixture : Multi-Purpose Lubricant The Blaster Corporation 8500 Sweet Valley Drive Valley View, Ohio 44125 - USA T (216) 901-5800 - F (216) 901-5801 www.blasterproducts.com Emergency number : Chemtrec (800) 424-9300 SECTION 2: Hazards identification GHS-US classification Flammable Aerosol 2 Gases Under Pressure ? Dissolved Gas Acute Toxicity 4 (Inhalation) Aspiration Toxicity 1 GHS-US labelling This product is a consumer product and is labeled in accordance with the US Consumer Product Safety Commission regulations which take precedence over OSHA Hazard Communication labeling. The actual container label will not include the label elements below. The labeling below applies to industrial/professional products. Hazard pictograms (GHS-US) : GHS02 GHS04 GHS07 GHS08 Signal word (GHS-US) : Danger Hazard statements (GHS-US) : Contains gas under pressure; may explode if heated. Flammable aerosol. Harmful if inhaled. May be fatal if swallowed and enters airways. Precautionary statements (GHS-US) : Keep away from heat/sparks/open flames/hot surfaces. -No smoking. Do not spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn, even afteruse. Avoid breathing dust/fume/gas/mist/vapors/spray. Use only outdoors or in a well-ventilated area. If inhaled: Remove person to fresh air and keep comfortable for breathing. Call apoison center/doctor if you feel unwell. If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. Store in a well-ventilated place. Protect from sunlight. Do not expose to temperatures exceeding 50 ?C/122 ?F. Store locked up. Dispose of contents and container in accordance with all local, regional, national and international regulations. No additional information available. 2 percent of the mixture consists of ingredient(s) of unknown acute toxicity. SECTION 3: Composition/information on ingredients Not applicable. 3.2. Mixture Name Product identifier % GHS-US classification Petroleum distillates, hydrotreated light (CAS No) 64742-47-8 30 - 60 Flam. Liq. 3 Asp. Tox. 1 1.1. Product identifier 1.2. Relevant identified uses of the substance or mixture and uses advised against 1.3. Details of the supplier of the safety data sheet 1.4. Emergency telephone number 2.1. Classification of the substance or mixture 2.2. Label elements 2.3. Other hazards 2.4. Unknown acute toxicity (GHS-US) 3.1. Substance Chain and Cable Lubricant Safety Data Sheet according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012 01/05//2016 EN (English) 2/6 Distillates, petroleum, hydrotreated light naphthenic (CAS No) 64742-53-6 30 - 60 Acute Tox. 4 (Inhalation) Asp. Tox. 1 Carbon dioxide (CAS No) 124-38-9 1 - 5 Compressed gas * The exact percentage (concentration) of composition has been withheld as a trade secret in accordance with paragraph (i) of ?1910.1200. SECTION 4: First aid measures First-aid measures after inhalation : If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical advice/attention if you feel unwell. First-aid measures after skin contact : In case of contact, immediately flush skin with plenty of water. Call a physician if irritation develops and persists. First-aid measures after eye contact : In case of contact, immediately flush eyes with plenty of water. Remove contact lenses, if worn. If irritation persists, get medical attention. First-aid measures after ingestion : If swallowed, do NOT induce vomiting. Never give anything by mouth to an unconscious person. Get immediate medical advice/attention. Symptoms/injuries after inhalation : Harmful if inhaled. May cause respiratory tract irritation. May cause headache, dizziness, nausea, vomiting and malaise. Symptoms/injuries after skin contact : May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/injuries after eye contact : May cause eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling. Symptoms/injuries after ingestion : May be fatal if swallowed and enters airways. This product may be aspirated into the lungs and cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible). SECTION 5: Firefighting measures Suitable extinguishing media : Foam, carbon dioxide, dry chemicals, halons. Halon may decompose into toxic materials and carbon dioxide will displace oxygen, take proper precautions when using these materials. Unsuitable extinguishing media : None known. Fire hazard : Flammable aerosol. Products of combustion may include, and are not limited to: oxides of carbon, oxides of nitrogen. Explosion hazard : Heat may build pressure, rupturing closed containers, spreading fire and increasing risk of burns and injuries. Firefighting instructions : Cool closed containers exposed to fire with water. Protection during firefighting : Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA). Material will float on water, avoid spreading the fire. SECTION 6: Accidental release measures General measures : Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel. Eliminate sources of ignition. For containment : Contain and/or absorb spill with inert material (e.g. sand, vermiculite), then place in a suitable container. Do not flush to sewer or allow to enter waterways. Use appropriate Personal Protective Equipment (PPE). Methods for cleaning up : Scoop up material and place in a disposal container. Vapours may be heavier than air and may travel along the ground to a distant ignition source and flash back. Provide ventilation. See section 8 for further information on protective clothing and equipment and section 13 for advice on waste disposal. 4.1. Description of first aid measures 4.2. Most important symptoms and effects, both acute and delayed 4.3. Indication of any immediate medical attention and special treatment needed 5.1. Extinguishing media 5.2. Special hazards arising from the substance or mixture 5.3. Advice for firefighters 6.1. Personal precautions, protective equipment and emergency procedures 6.2. Methods and material for containment and cleaning up 6.3. Reference to other sections Chain and Cable Lubricant Safety Data Sheet according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012 01/05//2016 EN (English) 3/6 SECTION 7: Handling and storage Precautions for safe handling : Keep away from sources of ignition. - No smoking. Avoid contact with skin and eyes. Avoid breathing dust/fume/gas/mist/vapours/spray. Do not swallow. When using do not eat, drink or smoke. Do not spray on an open flame or other ignition source. Use only outdoors or in a well- ventilated area. Pressurized container: Do not pierce or burn, even after use. Hygiene measures : Launder contaminated clothing before reuse. Wash hands before eating, drinking, or smoking. Technical measures : Proper grounding procedures to avoid static electricity should be followed. Storage conditions : Keep locked up and out of reach of children. Do not expose to temperatures exceeding 50 ?C/ 122 ?F. Store away from direct sunlight or other heat sources. Keep dry. Storage area : Store in a well-ventilated place. Not available. SECTION 8: Exposure controls/personal protection Petroleum distillates, hydrotreated light (64742-47-8) ACGIH Not applicable OSHA Not applicable Distillates, petroleum, hydrotreated light naphthenic (64742-53-6) ACGIH Not applicable OSHA Not applicable Carbon dioxide (124-38-9) ACGIH ACGIH TWA (ppm) 5000 ppm ACGIH ACGIH STEL (ppm) 30000 ppm OSHA OSHA PEL (TWA) (mg/m?) 9000 mg/m? OSHA OSHA PEL (TWA) (ppm) 5000 ppm Appropriate engineering controls : Use ventilation adequate to keep exposures (airborne levels of dust, fume, vapor, etc.) below recommended exposure limits. Ensure that eyewash stations and safety showers are close to the workstation location. Hand protection : Wear chemically resistant protective gloves. Eye protection : Safety glasses or goggles are recommended when using product. Skin and body protection : Wear suitable protective clothing. Respiratory protection : A NIOSH approved respirator is recommended in poorly ventilated areas or when permissible exposure limits may be exceeded. Environmental exposure controls : Maintain levels below Community environmental protection thresholds. Other information : Do not eat, smoke or drink where material is handled, processed or stored. Wash hands carefully before eating or smoking. Handle according to established industrial hygiene and safety practices. SECTION 9: Physical and chemical properties Physical state : Gas/Pressurized Liquid Appearance : Hazy Colour : Milky Odour : Mild aliphatic Odour threshold : No data available pH : No data available Relative evaporation rate (butylacetate=1) : No data available Melting point : No data available Freezing point : No data available 7.1. Precautions for safe handling 7.2. Conditions for safe storage, including any incompatibilities 7.3. Specific end use(s) 8.1. Control parameters 8.2. Exposure controls 9.1. Information on basic physical and chemical properties Chain and Cable Lubricant Safety Data Sheet according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012 01/05//2016 EN (English) 4/6 Boiling point : 193.3 ?C (380 ?F) Flash point : 62.8 ?C (145 ?F) TCC Auto-ignition temperature : No data available Decomposition temperature : No data available Flammability (solid, gas) : Flammable Vapour pressure : No data available Relative vapour density at 20 ?C : No data available Relative density : 0.84 Solubility : No data available Log Pow : No data available Log Kow : No data available Viscosity, kinematic : No data available Viscosity, dynamic : No data available Explosive properties : No data available Oxidising properties : No data available Explosive limits : No data available Flashback present : No Flame projection length : 0 cm Heat of combustion : 49.7 kJ/g SECTION 10: Stability and reactivity No dangerous reaction known under conditions of normal use. Stable under normal storage conditions. Flammable aerosol. Contents under pressure. Container may explode if heated. Do not puncture. Do not burn. No dangerous reaction known under conditions of normal use. Heat. Incompatible materials. Sources of ignition. Strong oxidizing agents. May include, and are not limited to: oxides of carbon, oxides of nitrogen. SECTION 11: Toxicological information Acute toxicity : Harmful if inhaled. Chain and Cable Lube LD50 oral rat > 2000 mg/kg LD50 dermal rabbit > 2000 mg/kg LC50 inhalation rat >1.0 but ?5.0 mg/l/4h Petroleum distillates, hydrotreated light (64742-47-8) LD50 oral rat > 5000 mg/kg LD50 dermal rabbit > 2000 mg/kg LC50 inhalation rat > 5.2 mg/l/4h Distillates, petroleum, hydrotreated light naphthenic (64742-53-6) LD50 oral rat > 5000 mg/kg LD50 dermal rabbit > 2000 mg/kg LC50 inhalation rat 2.18 mg/l/4h Skin corrosion/irritation : Based on available data, the classification criteria are not met. Serious eye damage/irritation : Based on available data, the classification criteria are not met. 9.2. Other information 10.1. Reactivity 10.2. Chemical stability 10.3. Possibility of hazardous reactions 10.4. Conditions to avoid 10.5. Incompatible materials 10.6. Hazardous decomposition products 11.1. Information on toxicological effects Chain and Cable Lubricant Safety Data Sheet according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012 01/05//2016 EN (English) 5/6 Respiratory or skin sensitisation : Based on available data, the classification criteria are not met. Germ cell mutagenicity : Based on available data, the classification criteria are not met. Carcinogenicity : Based on available data, the classification criteria are not met. Reproductive toxicity : Based on available data, the classification criteria are not met. Specific target organ toxicity (single exposure) : Based on available data, the classification criteria are not met. Specific target organ toxicity (repeated exposure) : Based on available data, the classification criteria are not met. Aspiration hazard : May be fatal if swallowed and enters airways. Symptoms/injuries after inhalation : Harmful if inhaled. May cause respiratory tract irritation. May cause headache, dizziness, nausea, vomiting and malaise. Symptoms/injuries after skin contact : May cause skin irritation. Symptoms may include redness, drying, defatting and cracking of the skin. Symptoms/injuries after eye contact : May cause eye irritation. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling. Symptoms/injuries after ingestion : May be fatal if swallowed and enters airways. This product may be aspirated into the lungs and cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. SECTION 12: Ecological information 12.1. Toxicity Ecology - general : May cause long-term adverse effects in the aquatic environment. 12.2. Persistence and degradability Chain and Cable Lube Persistence and degradability Not established. 12.3. Bioaccumulative potential Chain and Cable Lube Bioaccumulative potential Not established. 12.4. Mobility in soil No additional information available. 12.5. Other adverse effects Effect on the global warming : No known ecological damage caused by this product. SECTION 13: Disposal considerations 13.1. Waste treatment methods Waste disposal recommendations : This material must be disposed of in accordance with all local, state, provincial, and federal regulations. The generation of waste should be avoided or minimized wherever possible. Additional information : Flammable vapours may accumulate in the container. Do not incinerate empty containers. SECTION 14: Transport information In accordance with DOT UN-No.(DOT) : UN1950 Proper Shipping Name (DOT) : AEROSOLS, flammable, limited quantities Department of Transportation (DOT) Hazard Classes : 2.1 Hazard labels (DOT) : Packing group (DOT) : Not applicable Additional information Other information : No supplementary information available. Special transport precautions : Do not handle until all safety precautions have been read and understood. Chain and Cable Lubricant Safety Data Sheet according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012 01/05//2016 EN (English) 6/6 SECTION 15: Regulatory information 15.1. US Federal regulations All components of this product are listed, or excluded from listing, on the United States Environmental Protection Agency Toxic Substances Control Act (TSCA) inventory. 15.2. US State regulations Chain and Cable Lube State or local regulations This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. SECTION 16: Other information Indication of changes : None. Date of issue : 01/05/2016 Other information : None. Disclaimer: We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information contained in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. It is the user?s responsibility to satisfy oneself as to the suitability and completeness of this information for the user?s own particular use. Chain and Cable Lubricant Safety Data Sheet SECTION 1: Identification of the substance/mixture and of the company/undertaking SECTION 2: Hazards identification GHS-US classification SECTION 3: Composition/information on ingredients SECTION 4: First aid measures SECTION 5: Firefighting measures SECTION 6: Accidental release measures SECTION 7: Handling and storage SECTION 8: Exposure controls/personal protection SECTION 9: Physical and chemical properties SECTION 10: Stability and reactivity SECTION 11: Toxicological information SECTION 12: Ecological information 12.1. Toxicity 12.2. Persistence and degradability 12.5. Other adverse effects SECTION 13: Disposal considerations 13.1. Waste treatment methods SECTION 14: Transport information Additional information SECTION 15: Regulatory information 15.1. US Federal regulations 15.2. US State regulations