12/21/2015Revision: Page: 1 Rubberized Undercoating SAFETY DATA SHEET 06/14/2013Supersedes Revision: C35Product Code: Rubberized UndercoatingProduct Name: CYCLO INDUSTRIES, INC.Company Name: 902 SOUTH US HIGHWAY 1 JUPITER, FL 33477 First Aid EmergencyEmergency Contact: (800)752-7869 CHEMTREC (703) 527-3887 (800)424-9300 First Aid Emergency (Outside U.S.)Information: (312)906-6194 (800)843-7813 Phone Number: www.cyclo.comWeb site address: 1. Product and Company Identification This email address is being protected from spambots. You need JavaScript enabled to view it. address: 2. Hazards Identification P233: Keep container tightly closed. P210: Keep away from heat/sparks/open flames/hot surfaces - No smoking. P280: Wear protective gloves/protective clothing/eye protection/face protection. P240: Ground/bond container and receiving equipment. P241: Use explosion-proof electrical/ventilating/lighting equipment. P243: Take precautionary measures against static discharge. P242: Use only non-sparking tools. P201: Obtain special instructions before use. P202: Do not handle until all safety precautions have been read and understood. P281: Use personal protective equipment as required. P271: Use only outdoors or in a well-ventilated area. P261: Avoid breathing dust/fume/gas/mist/vapours/spray. GHS Precaution Phrases: P370+378: In case of fire, use alcohol, foam, CO2, dry chemical or water fog to extinguish. P301+330+331: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. P304+340: IF INHALED: Remove victim to fresh air and keep at rest in a position GHS Response Phrases: H222: Extremely flammable aerosol. H224: Extremely flammable liquid and vapor. H229: Pressurized container: may burst if heated H340: May cause genetic defects. H350: May cause cancer. H361: Suspected of damaging fertility or the unborn child. H335: May cause respiratory irritation. H373: May cause damage to organs through prolonged or repeated exposure. H304: May be fatal if swallowed and enters airways. H280: Contents under pressure. May explode if heated. GHS Hazard Phrases: Flammable Liquids, Category 1 Germ Cell Mutagenicity, Category 1B Carcinogenicity, Category 1B Toxic To Reproduction, Category 2 Specific Target Organ Toxicity (single exposure), Category 3 Specific Target Organ Toxicity (repeated exposure), Category 2 Aspiration Toxicity, Category 1 DangerGHS Signal Word: MIRS MSDS, (c) A V Systems, Inc. GHS format 12/21/2015Revision: Page: 2 Rubberized Undercoating SAFETY DATA SHEET 06/14/2013Supersedes Revision: comfortable for breathing. P303+361+353: IF ON SKIN (or hair): Remove/take off immediately all contaminated clothing. Rinse skin with water/shower. P363: Wash contaminated clothing before reuse. P305+351+338: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P309+311: Call a POISON CENTER or doctor/physician if exposed or you feel unwell. P501: Dispose of contents/container in accordance with local/regional/national/international regulation. P403+233: Store container tightly closed in well-ventilated place. GHS Storage and Disposal Phrases: Persons with a history of chronic skin or respiratory disorders may be at an increased risk for worsening of their conditions from exposure to this product. Medical Conditions Generally Aggravated By Exposure: No data available.Potential Health Effects (Acute and Chronic): CAS # Hazardous Components (Chemical Name) 3. Composition/Information on Ingredients Concentration 1317-65-3 Calcium Carbonate 30.0 -35.0 % 68476-86-8 Liquified petroleum gas, sweetened 15.0 -20.0 % 108-88-3 Toluene 15.0 -20.0 % 79-20-9 Methyl acetate (Methyl ester of acetic acid} 10.0 -15.0 % 67-64-1 Acetone 1.0 -5.0 % 4. First Aid Measures If swallowed, do not induce vomiting. If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. In case of skin contact, wash area with soap and water. Remove contaminated clothing. Wash contaminated clothing before reuse. IIf in eyes, rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Call physician immediately if adverse reaction occurs. Emergency and First Aid Procedures: 5. Fire Fighting Measures Flash Pt: -156.00 F (-104.4 C) Method Used: Pensky-Marten Closed Cup Containers can build up pressure if exposed to heat (fire). As in any fire, wear self-contained breathing apparatus pressure-demand (MSHA/NIOSH approved or equivalent) and full protective gear. Water runoff can cause environmental damage. Dike and collect water used to fight fire. Keep containers and surroundings cool with water spray. Beware of vapors accumulating to form explosive concentrations. Vapors can accumulate in low areas. Fire Fighting Instructions: Vapors may form explosive mixture with air. Vapors can travel to a source of ignition and flash back. "Empty" containers retain product residue (liquid and/or vapor) and can be dangerous. Do not pressurize, cut, weld, braze, solder, drill, grind or expose such containers to heat, flame, sparks, static electricity or other sources of ignition; they may explode and cause injury or death. Contents under pressure. Containers may explode if exposed to high temperatures. Flammable Properties and Hazards: Autoignition Pt: No data. Explosive Limits: LEL: 1.2 UEL: 16 Flammability Classification: NFPA Level 3 Aerosol Alcohol, foam, CO2, dry chemical, water fog.Suitable Extinguishing Media: MIRS MSDS, (c) A V Systems, Inc. GHS format 12/21/2015Revision: Page: 3 Rubberized Undercoating SAFETY DATA SHEET 06/14/2013Supersedes Revision: No data available. 6. Accidental Release Measures Use recommended personal protective equipment. Absorb spill with inert material (e.g. dry sand or earth), then place in a chemical waste container. Avoid runoff into storm sewers and ditches which lead to waterways. Do not flush into surface water or sanitary sewer system. Steps To Be Taken In Case Material Is Released Or Spilled: 7. Handling and Storage Keep container tightly closed. Keep away from heat/sparks/open flames/hot surfaces - No smoking. Wear protective gloves/protective clothing/eye protection/face protection. Ground/bond container and receiving equipment. Use explosion-proof electrical/ventilating/lighting equipment. Take precautionary measures against static discharge. Use only non-sparking tools. Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Use personal protective equipment as required. Use only outdoors or in a well-ventilated area. Avoid breathing dust/fume/gas/mist/vapours/spray. Keep out of the reach of children. Precautions To Be Taken in Handling: Store container tightly closed in well-ventilated place.Precautions To Be Taken in Storing: 8. Exposure Controls/Personal Protection OSHA TWA ACGIH TWACAS # Partial Chemical Name Other Limits No data.PEL: 15 (dust); 5 (resp.) mg/m3 No data. 1317-65-3 Calcium Carbonate No data.No data. No data. 68476-86-8 Liquified petroleum gas, sweetened No data.PEL: 200 ppm STEL: 500 ppm/(10min) CEIL: 300 ppm TLV: 50 ppm 108-88-3 Toluene No data.PEL: 200 ppm TLV: 200 ppm STEL: 250 ppm 79-20-9 Methyl acetate (Methyl ester of acetic acid} No data.PEL: 1000 ppm TLV: 500 ppm STEL: 750 ppm 67-64-1 Acetone A NIOSH/MSHA approved air purifying respirator with an organic vapor cartridge or canister may be permissible under certain circumstances where airborne concentrations are expected to exceed exposure limits. Protection provided by air purifying respirators is limited. Use a positive pressure air supplied respirator if there is any potential for an uncontrolled release, exposure levels are not known, or any other circumstances where air purifying respirators may not provide adequate protection. A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2 requirements must be followed whenever workplace conditions warrant a respirator's use. Respiratory Equipment (Specify Type): Safety glasses with side shields or goggles.Eye Protection: Impervious gloves (e.g. Viton gloves or Teflon gloves).Protective Gloves: Where splashing is possible, full chemically resistant protective clothing (e.g. acid suit) and boots are required. Other Protective Clothing: Local exhaust ventilation may be necessary to control any air contaminants to withing their TLVs during the use of this product. Use explosion proof ventilation equipment. Engineering Controls (Ventilation etc.): Wash hands before eating. Remove contaminated clothing and wash before reuse. Use only in well ventilated area. Follow all MSDS/label precautions even after container is emptied because they may retain product residues. Ground and bond containers when Work/Hygienic/Maintenance Practices: MIRS MSDS, (c) A V Systems, Inc. GHS format 12/21/2015Revision: Page: 4 Rubberized Undercoating SAFETY DATA SHEET 06/14/2013Supersedes Revision: transferring material. Use spark-proof tools and explosion-proof equipment. 9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Melting Point: No data. Boiling Point: No data. Flash Pt: -156.00 F (-104.4 C) Method Used: Pensky-Marten Closed Cup Explosive Limits: LEL: 1.2 UEL: 16 Vapor Pressure (vs. Air or mm Hg): No data. Vapor Density (vs. Air = 1): No data. Evaporation Rate: No data. pH: NP Black liquid with solvent odor.Appearance and Odor: Flammability (solid, gas): No data available. Specific Gravity (Water = 1): 1.127 Solubility in Water: Negligible Autoignition Pt: No data. Percent Volatile: 37.55 % by weight. 10. Stability and Reactivity Avoid open flames and high temperatures, all sources of ignition and welding arcs. Temperatures above 120 F. Conditions To Avoid - Instability: Unstable [ ] Stable [ X ]Stability: May react with oxygen and strong oxidizing agents such as chlorates, nitrates, peroxides, etc. Avoid contact with strong oxidizers. Incompatibility - Materials To Avoid: Carbon monoxide, carbon dioxide, smoke, fumes.Hazardous Decomposition or Byproducts: Will occur [ ] Will not occur [ X ]Possibility of Hazardous Reactions: No data available.Conditions To Avoid - Hazardous Reactions: MIRS MSDS, (c) A V Systems, Inc. GHS format 12/21/2015Revision: Page: 5 Rubberized Undercoating SAFETY DATA SHEET 06/14/2013Supersedes Revision: CAS # Hazardous Components (Chemical Name) NTP 11. Toxicological Information No data available.Toxicological Information: IARC ACGIH OSHA 1317-65-3 Calcium Carbonate n.a. n.a. n.a. n.a. 68476-86-8 Liquified petroleum gas, sweetened n.a. n.a. n.a. n.a. 108-88-3 Toluene n.a. 3 A4 n.a. 79-20-9 Methyl acetate (Methyl ester of acetic acid} n.a. n.a. n.a. n.a. 67-64-1 Acetone n.a. n.a. A4 n.a. No data available. 12. Ecological Information Dispose of contents/container in accordance with local/regional/national/international regulation. Waste Disposal Method: 13. Disposal Considerations 14. Transport Information Consumer CommodityDOT Proper Shipping Name: ORM-D ORM-DDOT Hazard Class: UN/NA Number: LAND TRANSPORT (US DOT): Aerosols, Flammable, 2.1, Ltd QtyADR/RID Shipping Name: LAND TRANSPORT (European ADR/RID): 1950UN Number: N.A.Hazard Class: 2.1ADR Classification: Aerosols, Ltd. Qty.IMDG/IMO Shipping Name: MARINE TRANSPORT (IMDG/IMO): 1950UN Number: Packing Group: N.A.Hazard Class: 2.1IMDG Classification: IMDG MFAG Number: IMDG EMS Page: NoMarine Pollutant: Aerosols, Flammable, 2.1, Ltd QtyICAO/IATA Shipping Name: AIR TRANSPORT (ICAO/IATA): 1950UN Number: N.A.Hazard Class: 2.1IATA Classification: CAS # Hazardous Components (Chemical Name) 15. Regulatory Information S. 302 (EHS) S. 304 RQ S. 313 (TRI) EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists 1317-65-3 Calcium Carbonate No No No 68476-86-8 Liquified petroleum gas, sweetened No No No 108-88-3 Toluene No Yes 1000 LB Yes 79-20-9 Methyl acetate (Methyl ester of acetic acid} No No No 67-64-1 Acetone No Yes 5000 LB No MIRS MSDS, (c) A V Systems, Inc. GHS format 12/21/2015Revision: Page: 6 Rubberized Undercoating SAFETY DATA SHEET 06/14/2013Supersedes Revision: CAS # Hazardous Components (Chemical Name) Other US EPA or State Lists 1317-65-3 Calcium Carbonate CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes - Inventory; CA PROP.65: No; CA TAC, Title 8: No; MA Oil/HazMat: No; MI CMR, Part 5: No; NC TAP: No; NJ EHS: Yes - 4001; NY Part 597: No; PA HSL: Yes - 1; SC TAP: No; WI Air: No 68476-86-8 Liquified petroleum gas, sweetened CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes - Inventory; CA PROP.65: No; CA TAC, Title 8: No; MA Oil/HazMat: No; MI CMR, Part 5: No; NC TAP: No; NJ EHS: No; NY Part 597: No; PA HSL: No; SC TAP: No; WI Air: No 108-88-3 Toluene CAA HAP,ODC: HAP; CWA NPDES: Yes; TSCA: Yes - Inventory, 8A CAIR; CA PROP.65: Yes; CA TAC, Title 8: TAC, Title 8; MA Oil/HazMat: Yes; MI CMR, Part 5: CMR, Part 5; NC TAP: Yes; NJ EHS: Yes - 1866; NY Part 597: Yes; PA HSL: Yes - E; SC TAP: Yes; WI Air: Yes 79-20-9 Methyl acetate (Methyl ester of acetic acid} CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes - Inventory, 4 Test, 8A PAIR; CA PROP.65: No; CA TAC, Title 8: Title 8; MA Oil/HazMat: Yes; MI CMR, Part 5: No; NC TAP: No; NJ EHS: No; NY Part 597: No; PA HSL: Yes - 1; SC TAP: No; WI Air: Yes 67-64-1 Acetone CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes - Inventory, 4 Test; CA PROP.65: No; CA TAC, Title 8: Title 8; MA Oil/HazMat: Yes; MI CMR, Part 5: Part 5; NC TAP: No; NJ EHS: Yes - 0006; NY Part 597: Yes; PA HSL: Yes - E; SC TAP: No; WI Air: Yes CAS # Hazardous Components (Chemical Name) International Regulatory Lists 1317-65-3 Calcium Carbonate Canadian DSL: No; Canadian NDSL: Yes; Taiwan TCSCA: Yes 68476-86-8 Liquified petroleum gas, sweetened Canadian DSL: Yes; Canadian NDSL: No; Taiwan TCSCA: Yes 108-88-3 Toluene Canadian DSL: Yes; Canadian NDSL: No; Taiwan TCSCA: Yes 79-20-9 Methyl acetate (Methyl ester of acetic acid} Canadian DSL: Yes; Canadian NDSL: No; Taiwan TCSCA: Yes 67-64-1 Acetone Canadian DSL: Yes; Canadian NDSL: No; Taiwan TCSCA: Yes 16. Other Information No data available.Additional Information About This Product: Hazard Rating System: Instability Special Hazard Health Flammability Cyclo Industries, Inc. provides the information contained herein in good faith but makes no representation as to its comprehensiveness or accuracy. Individuals receiving this information must exercise their independent judgment in determining its appropriateness for a particular purpose. Cyclo Industries, Inc. makes no representations or warranties, either expressed or implied, of merchantability, fitness for a particular purpose with respect to the information set forth herein or to the product to which the information Company Policy or Disclaimer: 2 4 0 12/21/2015Revision Date: NFPA: MIRS MSDS, (c) A V Systems, Inc. GHS format 12/21/2015Revision: Page: 7 Rubberized Undercoating SAFETY DATA SHEET 06/14/2013Supersedes Revision: refers. Accordingly, Cyclo Industries, Inc. will not be responsible for damages resulting from use of or reliance upon this information. MIRS MSDS, (c) A V Systems, Inc. GHS format