Trak Product Code: C1615 Page 1 of 8 SAFETY DATA SHEET SECTION 1 PRODUCT and COMPANY INFORMATION TRADE NAME: Castle? Trak? PRODUCT TYPE: Belt Dressing PRODUCT CODE: C1615 MANUFACTURED FOR: Castle Products, Inc. 424 St. Paul Street Rochester, NY 14605 (800) 876-0222 EMERGENCY (585) 275-3232 SECTION 2 HAZARDS IDENTIFICATION Classification Skin corrosion/irritation Category 2 Serious eye damage/eye irritation Category 2B Reproductive Toxicity Category 2 Specific target organ toxicity (single exposure) Category 3 Specific target organ toxicity (repeated exposure) Category 2 Aspiration toxicity Category 1 GHS Label elements, including precautionary statements Emergency Overview Flammable aerosols Category 1 Gases under pressure Compressed Gas DANGER Hazard Statements Causes skin irritation Causes eye irritation Suspected of damaging fertility or the unborn child May cause respiratory irritation. May cause drowsiness or dizziness May cause damage to organs (Central Nervous System, Eyes,Respiratory System, Skin, and Peripheral Nervous System ) through prolonged or repeated exposure. May be fatal if swallowed and enters airways Extremely flammable aerosol Contains gas under pressure; may explode if heated Appearance No information available Physical state Aerosol Odor Solvent Trak Product Code: C1615 Page 2 of 8 Precautionary Statements - Prevention Obtain special instructions before use Do not handle until all safety precautions have been read and understood Wear protective gloves/protective clothing/eye protection/face protection Wash face, hands and any exposed skin thoroughly after handling Do not breathe dust/fume/gas/mist/vapors/spray Use only outdoors or in a well-ventilated area Keep away from heat/sparks/open flames/hot surfaces. ? No smoking Do not spray on an open flame or other ignition source Pressurized container: Do not pierce or burn, even after use Precautionary Statements - Response If exposed or concerned: Get medical advice/attention Specific treatment (see first aid on this label) IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention Take off contaminated clothing and wash before reuse CAS # 64742-49-0, COMMERCIAL HEXANES, MAY BE SUBSTITUTED FOR CAS #110-54-3. Chemical Name CAS-No Weight %* HEXANE 64742-49-0 30-40 DIMETHYLETHER 115-10-6 20-30 MINERAL SPIRITS 64742-88-7 1-10 *The exact percentage (concentration) of composition has been withheld as a trade secret. IF INHALED: Remove person to fresh air and keep comfortable for breathing. Call a POISON CENTER or doctor/physician if you feel unwell IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician Do NOT induce vomiting Precautionary Statements - Storage Store locked up Store in a well-ventilated place. Keep container tightly closed Protect from sunlight. Do not expose to temperatures exceeding 50 ?C/122 ?F Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) None Other information ? Harmful to aquatic life with long lasting effects 0% of the mixture consists of ingredient(s) of unknown toxicity SECTION 3 COMPOSITION INFORMATION ON INGREDIENTS Trak Product Code: C1615 Page 3 of 8 First aid measures for different exposure routes Eye contact Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Keep eye wide open while rinsing. If symptoms persist, call a physician. Skin contact Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If skin irritation persists, call a physician. Inhalation Move to fresh air. If breathing is difficult, give oxygen. Artificial respiration and/or oxygen may be necessary. If breathing has stopped, contact emergency medical services immediately. Ingestion Rinse mouth. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Drink plenty of water. Call a physician or Poison Control Center immediately. Most important symptoms/effects, acute and delayed Main Symptoms Causes skin irritation. Causes eye irritation. May cause respiratory irritation.May be harmful if swallowed. Indication of immediate medical attention and special treatment needed, if necessary SECTION 4 FIRST AID MEASURES Notes to physician Treat symptomatically. SECTION 5 FIRE FIGHTING MEASURES Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media Decomposition by contact with water may generate vapors which can be ignited by heat or open flame. Specific hazards arising from the chemical Extremely flammable. Explosion Data Sensitivity to Mechanical Impact none. Sensitivity to Static Discharge Yes. Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. SECTION 6 ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Absorb with sand, clay, or other suitable material. Hard surfaces may be mopped with water. Remove all sources of ignition. Avoid contact with the skin and the eyes. Evacuate personnel to be safe areas.Keep people away from and upwind of spill/leak. Contents under pressure. Do not puncture or incinerate cands. Wear protective gloves/clothing and eye/face protection. Environmental precautions Environmental precautions Do not flush into surface water or sanitary sewer system. Beware of vapors accumulating to form explosive concentrations. Vapors can accumulate in low areas. Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. Trak Product Code: C1615 Page 4 of 8 Methods and materials for containment and cleaning up Methods for Containment Absorb with earth, sand or other non-combustible material and transfer to containers for later disposal. Prevent further leakage or spillage if safe to do so. Methods for cleaning up Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. Clean contaminated surface thoroughly. After cleaning, flush away traces with water. Prevent product from entering drains. Precautions for safe handling Advice on safe handling Avoid contact with eyes. Avoid breathing vapors or mists. Contents under pressure. Do not puncture or incinerate cans. Do not stick pin or any other sharp object into opening on top of can. Conditions for safe storage, including any incompatibilities Technical measures/Storage conditions Keep container tightly closed in a dry and well-ventilated place. Keep containers tightly closed in a cool, well-ventilated place. Keep in properly labeled containers. Keep out of the reach of children. Store locked up. Incompatible products Strong acids, alkalis, or oxidizing agents. SECTION 7 HANDLING AND STORAGE Aerosol Level 3 SECTION 8 EXPOSURE CONTROLS / PERSONAL PROTECTION Control parameters Exposure Guidelines . Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH HEXANE 64742-49-0 TWA: 50 ppm Skin - potential significant contribution to overall exposure by the cutaneous route TWA: 500 ppm TWA: 1800 mg/m3 (vacated) TWA: 50 ppm (vacated) TWA: 180 mg/m3 IDLH: 1100 ppm TWA: 50 ppm TWA: 180 mg/m3 ACGIH: (American Conference of Governmental Industrial Hygienists) OSHA: (Occupational Safety & Health Administration) NIOSH IDLH: Immediately Dangerous to Life or Health Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Exposure controls Engineering Measures Showers Eyewash stations Ventilation systems. Individual protection measures, such as personal protective equipment Eye/Face Protection Safety glasses with side-shields. Skin and body protection Chemical resistant apron. Protective gloves. Respiratory protection If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. Positive-pressure supplied air respirators may be required for high airborne contaminant concentrations. Respiratory protection must be provided in accordance with current local regulations. Hygiene measures Handle in accordance with good industrial hygiene and safety practice. Trak Product Code: C1615 Page 5 of 8 Physical and chemical properties Physical state Aerosol Appearance No information available Odor Solvent Color dark amber Odor Threshold No information available Property Values Remarks ? Methods pH No information available Melting/freezing point No information available Boiling point/boiling range No information available Flash Point -41 ?C / -42 ?F Evaporation rate No information available Flammability (solid, gas) No information available Flammability Limits in Air upper flammability limit No information available lower flammability limit No information available Vapor pressure No information available Vapor density No information available Specific Gravity 0.809 SECTION 9 PHYSICAL and CHEMICAL PROPERTIES Explosive properties No information available Other information VOC Content(%) 66.97 Water solubility Practically insoluble Partition coefficient: n-octanol/waterNo information available Autoignition temperature No information available Not applicable Decomposition temperature No information available Viscosity No information available SECTION 10 STABILITY and REACTIVITY DATA Reactivity Chemical stability Stable under recommended storage conditions. Possibility of hazardous reactions None under normal processing. Conditions to Avoid Extremes of temperature and direct sunlight. Incompatible Materials Strong acids, alkalis, or oxidizing agents. Hazardous Decomposition Products None known based on information supplied. No data available SECTION 11 TOXICOLOGICAL INFORMATION Information on likely routes of exposure Product Information Inhalation Vapors may irritate throat and respiratory system. May cause drownsiness and dizziness based on components. May cause irritation of respiratory tract. Avoid breathing vapors or mists. Eye contact Irritating to eyes. Avoid contact with eyes. Skin contact Irritating to skin. Repeated exposure may cause skin dryness or cracking. Prolonged skin contact may defat the skin and produce dermatitis. Avoid contact with skin. Ingestion May be harmful or fatal if swallowed. Aspiration into the lungs during swallowing may cause serious lung damage which may be fatal. Trak Product Code: C1615 Page 6 of 8 Component Information Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation HEXANE 64742-49-0 > 5000 mg/kg ( Rat ) > 3160 mg/kg ( Rabbit ) = 73680 ppm ( Rat ) 4 h DIMETHYLETHER 115-10-6 - - = 308.5 mg/L ( Rat ) 4 h MINERAL SPIRITS 64742-88-7 > 5000 mg/kg ( Rat ) = 3000 mg/kg ( Rabbit ) > 5.28 mg/L ( Rat ) 4 h Information on toxicological effects Symptoms Symptoms of overexposure may be headache, tiredness, nausea, and vomiting. Causes respiratory irritation. Causes skin and eye irritation.Aspiration into the lungs during swallowing may cause serious lung damage which may be fatal. Delayed and immediate effects as well as chronic effects from short and long-term exposure Skin corrosion/irritation Irritating to skin. Eye damage/irritation Irritating to eyes. Irritation Irritating to eyes, respiratory system and skin. Sensitization None known. Germ Cell Mutagenicity None known. Carcinogenicity There are no known carcinogenic chemicals in this product. Reproductive toxicity Product is or contains a chemical which is a known or suspected reproductive hazard. Specific target organ systemic toxicity (single exposure) May cause respiratory irritation. May cause drowsiness and dizziness. Specific target organ systemic toxicity (repeated exposure) May cause damage to organs through prolonged or repeated exposure. Target Organ Effects Central nervous system, Eyes, Peripheral Nervous System (PNS), Respiratory system, Skin. Neurological effects Intentional misuse by deliberately concentrating and inhaling contents may be harmful or fatal. Aspiration hazard May be fatal if swallowed and enters airways. Numerical measures of toxicity - Product Information Unknown Acute Toxicity 0% of the mixture consists of ingredient(s) of unknown toxicity SECTION 12 ECOLOGICAL INFORMATION Ecotoxicity Chemical Name Toxicity to algae Toxicity to fish Toxicity to microorganisms Toxicity to daphnia and other aquatic invertebrates MINERAL SPIRITS 64742-88-7 450 mg/L EC50 Pseudokirchneriella subcapitata 96h 800 mg/L LC50 Pimephales promelas 96h static - 100 mg/L EC50 Daphnia magna 48h Persistence and degradability No information available. Bioaccumulation No information available. Chemical Name log Pow DIMETHYLETHER 115-10-6 -0.18 Other adverse effects No information available Trak Product Code: C1615 Page 7 of 8 Waste treatment Waste Disposal Methods This material, as supplied, is a hazardous waste according to federal regulations (40 CFR 261). Contaminated packaging Do not re-use empty containers. SECTION 13 DISPOSAL CONSIDERATIONS SECTION 14 TRANSPORT INFORMATION DOT Ground CONSUMER COMMODITY ORM-D or LIMITED QUANTITY IATA UN1950, AEROSOLS, FLAMMABLE, 2.1, LTD. QTY. IMDG UN1950, AEROSOLS, 2.1, LTD. QTY. SECTION 15 REGULATORY INFORMATION International Inventories Chemical Name TSCA DSL/NDSL EINECS/ELI NCS ENCS IECSC KECL PICCS AICS HEXANE X X X X X X X X DIMETHYLETHER X X X X X X X X MINERAL SPIRITS X X X X X X X X Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Commercial Chemical Substances/EU List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances CHINA - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances U.S. Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. SARA 311/312 Hazard Categories Acute Health Hazard Yes Chronic Health Hazard Yes Fire Hazard Yes Sudden Release of Pressure Hazard Yes Reactive Hazard no Clean Water Act This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42). CERCLA This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level pertaining to releases of this material. U.S. State Regulations Trak Product Code: C1615 Page 8 of 8 California Proposition 65 This product does not contain any known Proposition 65 chemicals. U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania DIMETHYLETHER 115-10-6 X X X MINERAL SPIRITS 64742-88-7 X EPA Pesticide Registration Number Not applicable Canada This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all the information required by the CPR. Chronic Hazard Star Legend Chronic Health Hazard: Repeated or prolonged exposure may cause central nervous system damage NFPA Health Hazard 2 Flammability 4 Instability 0 Physical and chemical hazards - HMIS Health Hazard 2* Flammability 4 Physical Hazard 1 Personal protection B SECTION 16 OTHER INFORMATION Disclaimer Terms and Conditions. This SDS is designed only as guidance for the products to which it applies. To the greatest extent permitted by applicable law, nothing contained herein creates any legal obligation including contractual obligations, expressed or implied warranties, including any warranties of merchantability or fitness for particular purpose; or confers any intellectual property rights, including rights to use trademarks or a license to use patents, issued or pending. The information contained herein is based on the manufacturer's own study and the work of others, and is subject to change at any time without further notice. There is no warranty, expressed or implied, as to the accuracy, completeness or adequacy of the information contained herein, and neither the provider nor the manufacturer (nor the agents, directors, officers, contractors or employees of either) are liable to any party for any damages of any nature, including direct, special or consequential damages arising out of or in connection with the accuracy, completeness, adequacy or furnishing of any information in this SDS, or in any other way related (directly or indirectly) to this SDS. The receipt and use of this information constitutes consent to these terms and conditions. Other: NA-Not Applicable, ND-Not Determined, NE-Not Established. PREPARED: 8/11/93 UPDATED: 8/18/16 PRODUCT #: C1615 Slide 1 Slide 2 Slide 3 Slide 4 Slide 5 Slide 6 Slide 7 Slide 8